Preparation of Natural Zeolite for Air Dehumidification in Food Drying

Mohamad Djaeni, Laeli Laeli Kurniasari, Setia Budi Sasongko


DOI: https://doi.org/10.12777/ijse.8.2.80-83

Abstract


Drying with air dehumidification with solid adsorbent improves the quality of food product as well as energy efficiency. The natural zeolite is one of adsorbent having potential to adsorb the water.  Normally, the material was activated to open the pore, remove the organic impurities, and increase Si/Al rate. Hence, it can enhance the adsorbing capacity. This research studied the activation of natural zeolite mined from Klaten, Indonesia as air dehumidification for food drying. Two different methods were used involving activation by heat and NaOH introduction.  As indicators, the porosity and water loaded were evaluated. Results showed both methods improved the adsorbing capacity significantly. With NaOH, the adsorbing capacity was higher. The simple test in onion and corn drying showed the presence of activated natural zeolite can speed up water evaporation positively. This performance was also comparable with Zeolite 3A

Keywords


adsorbent, capacity, onion, corn, water loaded

Full Text:

FULL TEXT PDF

References


(1) Djaeni, M., Bartels P.V., van Asselt, C.J., Sanders J.P.M., van Straten, G.; van Boxtel, A.J.B. (2009). Assessment of a two-stage zeolite dryer for energy efficient drying. Drying Technology, 27(11):1205-1216

(2) Revilla, G.O., Velázquez, T.G., Cortés, S.L., Cárdenas, S.A. (2006). Immersion drying of wheat using Al-PILC, zeolite, clay, and sand as particulate media. Drying Technology, 24(8): 1033-1038

(3) Ozkan F.C., Ulku S. (2008). Diffusion Mechanism of Water Vapour in A Zeolitic Tuff Rich in Clinoptilolite, Journal of Thermal Analysis and Calorimetry 94: 699-702

(4) Ackley M.W., Rege S.U., Saxena H. (2003). Application of Natural Zeolites in The Purification and Separation of Gases, Journal Microporous and Mesoporous Materials 61: 25-42

(5) Gruszkiewics M.S., Simonson, J.M., Burchell, T.D., Cole D.R. (2005). Water Adsorption and Desorption on Microporous Solids at Elevated Temperature, Journal of Thermal Analysis and Calorimetry 81: 609-615

(6) Senda, S.P., Saputra H., Sholeh A., Rosjidi M., Mustafa A. (2006). Prospek Aplikasi Produk Berbasis Zeolit untuk Slow Release Substances (SRS) dan Membran, Artikel Badan Pengkajian dan Penerapan Teknologi Indonesia, ISSN 1410-9891.

(7) Rosita N., Erawati T., Moegihardjo M. (2004). Pengaruh Perbedaan Metode Aktivasi Terhadap Efektivitas Zeolit sebagai Adsorben, Majalah Farmasi Airlangga Vol 4 No. 1.

(8) Ozkan F.C., Ulku S. (2005). The Effect of HCl Treatment on Water Vapor Adsorption Characteristics of Clinoptilolite Rich Natural Zeolite, Journal Microporous and Mesoporous Materials 77: 47-53.

(9) Bonenfant, D., Kharoune, M., Niquette, P., Mimeault, M., Hausler, R. (2008). Advances in Principal Factors Influencing Carbon Dioxide Adsorption on Zeolite; Sci. Technol. Adv. Mater 9, DOI 10.1088/1468-6996/9/1/013007

(10) Inglezakis, V.J., Papadeas, C.D., Loizidou, M.D., Grigoropoulou, H.P. (2001). Effects of Pretreatment on physical and Ion Exchange Properties of Natural Clinoptilolite, Environmental Technology Vol 22: 75-82

(11) Alikhan, Z., Raghavan, G.S.V., Mujumdar, A.S. (1992). Adsorption drying of corn in zeolite granules using a rotary drum. Drying Technology, 10(3): 783-797


Refbacks

  • There are currently no refbacks.


Published by Department of Chemical Engineering University of Diponegoro Semarang
Google Scholar

IJSE  by http://ejournal.undip.ac.id/index.php/ijse is licensed under Creative Commons Attribution 3.0 License.