Systematic Considerations for a Ballast Water Treatment System (BWTS) Retrofits: A Review

Wanda Rulita Sari, Gunawan Gunawan


DOI: https://doi.org/10.14710/kapal.v21i1.61944

Abstract


As a country that has more than half of the country's total territorial waters, Indonesia is highly dependent on shipping activities. Therefore, knowledge of policy updates for each ship from IMO must also be taken into account, one of which is the policy regarding the Ballast Water Management System, which requires every ship to be installed with a Ballast Water Treatment System in order to achieve the goal of a green environment in voyage areas by inhibiting the spread of microorganisms that endanger the area that is caused by ballast water. This regulatory update then creates problems, especially for ships that have been operating for a long time, because the ship has to comply with the standards for D-1 and then also have to comply with the D-2 standards according to the time specified in the convention. So, this review article will discuss the solution to the issues with retrofitting ballast water treatment systems as the addition of a new system to the existing system on a ship that has sailed and pay attention to conceptual aspects consisting of considerations and operations to find the type of ballast water treatment that suits each ship's needs by analyzing the advantages and disadvantages of each technology type method. There is also consideration for several stages that are commonly used to determine the type of treatment, starting with assessment and planning requirements, selection of space, compliance with BWMS regulations, selection of the ballast water treatment system method, engineering drawing, installation planning, and commissioning. Apart from that, several related innovation considerations were also discussed, including the development of alternative treatment technology, which has the potential for efficiency both in operational aspects and safety standards. Based on research developments, retrofitting the Ballast Water Treatment System with the ultra-violet (UV) treatment is well known as the common treatment beside the electrolysis treatment. The results obtained show that the ultra-violet (UV) method is one of the most efficient treatments when viewed from the way it works and the time duration for the treatment process. This proves that ultra-violet treatment can produce maximum efficiency if the selection of needs and consideration of maximized aspects also exceed the safety aspect as well.

Keywords


IMO, Ballast Water, Ballast Water Treatment System (BWTS), Retrofits

Full Text:

PDF

References


R. G. Magsino et al., “Students’ Onboard Experiences: Basis for Improved Shipboard Training Program Policy,” Int. J. English Lit. Soc. Sci., vol. 8, no. 2, pp. 259–274, 2023, doi: 10.22161/ijels.82.38.

N. Turgo, “Temporalities at sea: Fast time and slow time onboard ocean-going merchant vessels,” Ethnography, vol. 23, no. 4, pp. 473–495, 2022, doi: 10.1177/1466138120923371.

D. Medina-Rebollo, P. Sáenz-López Buñuel, E. J. Fernández-Ozcorta, and J. Fernández-Gavira, “The Use of Nautical Activities in Formal Education: A Systematic Review,” Behav. Sci. (Basel)., vol. 13, no. 11, 2023, doi: 10.3390/bs13110905.

S. C. Barry, K. R. Hayes, C. L. Hewitt, H. L. Behrens, E. Dragsund, and S. M. Bakke, “Ballast water risk assessment: Principles, processes, and methods,” ICES J. Mar. Sci., vol. 65, no. 2, pp. 121–131, 2008, doi: 10.1093/icesjms/fsn004.

J. A. Darling et al., “Ballast Water Exchange and Invasion Risk Posed by Intracoastal Vessel Traffic: An Evaluation Using High Throughput Sequencing,” Environ. Sci. Technol., vol. 52, no. 17, pp. 9926–9936, 2018, doi: 10.1021/acs.est.8b02108.

IMO, “International Convention for the Control and Manage- ment of Ship’s Ballast Water and Sediments,” BWM/CONG/36, 2004.

S. B. Kurniawan, D. S. A. Pambudi, M. M. Ahmad, B. D. Alfanda, M. F. Imron, and S. R. S. Abdullah, “Ecological impacts of ballast water loading and discharge: insight into the toxicity and accumulation of disinfection by-products,” Heliyon, vol. 8, no. 3, p. e09107, 2022, doi: 10.1016/j.heliyon.2022.e09107.

B. Werschkun et al., “Emerging risks from ballast water treatment: The run-up to the International Ballast Water Management Convention,” Chemosphere, vol. 112, pp. 256–266, 2014, doi: 10.1016/j.chemosphere.2014.03.135.

International Maritime Organization, “Annex 5 Code for Approval of Ballast Water Management Systems (BWMS CODE) Resolution MEPC.300(72),” Code Approv. ballast water Manag. Syst., vol. 300, no. April, pp. 1–41, 2018.

IMO, “Complying with the Ballast Water Management Convention Stopping the Spread of Invasive Aquatic Species.” 2017.

Y. Chen, J. Xue, W. Feng, J. Du, and H. Wu, “Bloom forming species transported by ballast water under the management of D-1 and D-2 standards—Implications for current ballast water regulations,” Mar. Pollut. Bull., vol. 194, no. PB, p. 115391, 2023, doi: 10.1016/j.marpolbul.2023.115391.

S. Gollasch, M. David, M. Voigt, E. Dragsund, C. Hewitt, and Y. Fukuyo, “Critical review of the IMO international convention on the management of ships’ ballast water and sediments,” Harmful Algae, vol. 6, no. 4, pp. 585–600, 2007, doi: 10.1016/j.hal.2006.12.009.

S. Banerji, B. Werschkun, and T. Höfer, “Assessing the risk of ballast water treatment to human health,” Regul. Toxicol. Pharmacol., vol. 62, no. 3, pp. 513–522, 2012, doi: 10.1016/j.yrtph.2011.11.002.

C. B. Güney, D. B. Danışman, and Ş. N. Ertürk Bozkurtoğlu, “Reduction of ballast tank sediment: Evaluating the effect of minor structural changes and developing a pneumatic cleaning system,” Ocean Eng., vol. 203, no. November 2019, 2020, doi: 10.1016/j.oceaneng.2020.107204.

M. Tadros, M. Ventura, and C. G. Soares, “Review of current regulations, available technologies, and future trends in the green shipping industry,” Ocean Eng., vol. 280, no. April, p. 114670, 2023, doi: 10.1016/j.oceaneng.2023.114670.

T. K. Liu, Y. C. Wang, and P. H. Su, “Implementing the ballast water management convention: Taiwan’s experience and challenges in the early stage,” Mar. Policy, vol. 109, no. October, p. 103706, 2019, doi: 10.1016/j.marpol.2019.103706.

R. Rivas-Hermann, J. Köhler, and A. E. Scheepens, “Innovation in product and services in the shipping retrofit industry: A case study of ballast water treatment systems,” J. Clean. Prod., vol. 106, no. April 2014, pp. 443–454, 2015, doi: 10.1016/j.jclepro.2014.06.062.

B. Sayinli, Y. Dong, Y. Park, A. Bhatnagar, and M. Sillanpää, “Recent progress and challenges facing ballast water treatment – A review,” Chemosphere, vol. 291, no. July 2021, 2022, doi: 10.1016/j.chemosphere.2021.132776.

L. Maglić, D. Zec, and V. Frančić, “Effectiveness of A Barge-Based Ballast Water Treatment Syste for Multi-Terminal Ports,” Promet - Traffic - Traffico, vol. 27, no. 5, pp. 429–437, 2015, doi: 10.7307/ptt.v27i5.1812.

K. G. N. Nanayakkara, Y. M. Zheng, and J. P. Chen, “Development and optimization of a highly effective and low energy intensive electro-disinfection system for ballast water treatment,” AIChE Annu. Meet. Conf. Proc., no. October, 2008.

M. Basuki, L. Lukmandono, and M. M. Zau Beu, “Ballast Water Management at Inaport 4th Makasar Based Environmental Risk Assessment,” SSRN Electron. J., no. 2014, pp. 29–30, 2020, doi: 10.2139/ssrn.3512750.

W. Feng, Q. Wang, Y. Chen, J. Wang, C. Guo, and H. Wu, “Diversity variation of zooplankton and phytoplankton communities in ship ballast water during the maiden voyage,” Reg. Stud. Mar. Sci., vol. 70, no. July 2023, p. 103345, 2023, doi: 10.1016/j.rsma.2023.103345.

N. D. Thach and P. Van Hung, “Development of UV reactor controller in ballast water treatment system to minimize the biological threat on marine environment,” J. Sea Res., p. 102465, 2023, doi: 10.1016/j.seares.2023.102465.

Y. Nfongmo Nkouefuth, F. M. Onana, E. Masseret, P. A. Nana, T. E. Ewoukem, and A. Kacimi, “Estimation of the introduction risk of non-indigenous species through ship ballast water in the Port of Douala (Cameroon),” Mar. Pollut. Bull., vol. 198, no. July 2023, p. 115794, 2024, doi: 10.1016/j.marpolbul.2023.115794.

S. I. Sezer, B. O. Ceylan, E. Akyuz, and O. Arslan, “D-S evidence based FMECA approach to assess potential risks in ballast water system (BWS) on-board tanker ship,” J. Ocean Eng. Sci., no. xxxx, 2022, doi: 10.1016/j.joes.2022.06.040.

T. Makkonen and T. Inkinen, “Systems of environmental innovation: sectoral and technological perspectives on ballast water treatment systems,” WMU J. Marit. Aff., vol. 20, no. 1, pp. 81–98, 2021, doi: 10.1007/s13437-021-00226-2.

Ž. Kurtela and P. Komadina, “Application of hydrocyclone and uv radiation as a ballast water treatment method,” Promet - Traffic - Traffico, vol. 22, no. 3, pp. 183–191, 2010, doi: 10.7307/ptt.v22i3.274.

M. S. Arif, H. A. Kurniawati, and M. N. Misbah, “Technical and Economic Analysis of Selection of Ship Ballast Water Management in Indonesia,” Kapal, vol. 13, no. 3, p. 126, 2016, doi: 10.14710/kpl.v13i3.12351.

M. Basuki, “Implementation Model of Government Regulations Regarding Ballast Water Management in Tanjung Perak Port Surabaya,” no. August, 2020.

K. Dong, W. Wu, J. Chen, J. Xiang, X. Jin, and HuixianWu, “A study on treatment efficacy of ballast water treatment system applying filtration + membrane separation + deoxygenation technology during shipboard testing,” Mar. Pollut. Bull., vol. 188, no. May 2022, p. 114620, 2023, doi: 10.1016/j.marpolbul.2023.114620.

L. Yuan, J. Xiang, J. Xue, Y. Lin, and H. Wu, “Recommendations for representative sampling methodologies in ballast water: A case study from the land-based test,” Mar. Pollut. Bull., vol. 197, no. October, p. 115814, 2023, doi: 10.1016/j.marpolbul.2023.115814.

G. Drillet et al., “Improvement in compliance of ships’ ballast water discharges during commissioning tests,” Mar. Pollut. Bull., vol. 191, no. April, p. 114911, 2023, doi: 10.1016/j.marpolbul.2023.114911.

B. Shomar and J. R. Solano, “Probabilistic human health risk assessment of trace elements in ballast water treated by reverse osmosis desalination plants,” Mar. Pollut. Bull., vol. 188, no. November 2022, p. 114667, 2023, doi: 10.1016/j.marpolbul.2023.114667.

H. Chatterjee, “Ballast Water Treatment Systems and Retrofitting Them on Container Ships,” 2015.

IMO, “Annex 10 Resolution MEP.289(71), 2017 Guidelines for Risk Assesment Under Regulation A-4 of the BWM Convention (G7),” vol. 289, no. July, 2017.

S. Buana, K. Yano, and T. Shinoda, “Design Evaluation Methodology for Ships ’ Outfitting Equipment by Applying Multi-criteria Analysis : Proper Choices Analysis of Ballast Water Management Systems,” vol. 13, no. September 2021, pp. 310–320, 2022, doi: 10.14716/ijtech.v13i2.5087.

IMO, “Guidance for Administrations on the type approval process for ballast water management systems,” Int. Conv. Control Manag. Ships’ Ballast Water Sediments, 2004, vol. 44, no. October, 2018.

DNV, “DNV Guidance - approval of retrofit installations of ballast water treatment systems,” Gen. Inf., no. November 2013, 2013.

J. H. Kwon, J. H. Jung, H. D. Lee, Y. S. Park, and D. W. Kim, “Development of a hydrodynamic static mixer for mixing chemicals in ballast water treatment systems,” J. Water Process Eng., vol. 8, pp. 209–220, 2015, doi: 10.1016/j.jwpe.2015.10.006.

Z. Yi et al., “Intelligent initial model and case design analysis of smart factory for shipyard in China,” Eng. Appl. Artif. Intell., vol. 123, no. May 2023, p. 106426, 2023, doi: 10.1016/j.engappai.2023.106426.

T. Satir, “Ballast water treatment systems : design , regulations , and selection under the choice varying priorities,” 2014, doi: 10.1007/s11356-014-3087-1.

P. G. Jang, B. Hyun, and K. Shin, “Ballast water treatment performance evaluation under real changing conditions,” J. Mar. Sci. Eng., vol. 8, no. 10, pp. 1–19, 2020, doi: 10.3390/jmse8100817.

W. A. Gerhard, K. Lundgreen, G. Drillet, R. Baumler, H. Holbech, and C. K. Gunsch, “Installation and use of ballast water treatment systems – Implications for compliance and enforcement,” Ocean Coast. Manag., vol. 181, no. April, p. 104907, 2019, doi: 10.1016/j.ocecoaman.2019.104907.

J. Jee and S. Lee, “Comparative feasibility study on retrofitting ballast water treatment system for a bulk carrier,” Mar. Pollut. Bull., vol. 119, no. 2, pp. 17–22, 2017, doi: 10.1016/j.marpolbul.2017.03.041.

E. Díaz-Domínguez, L. Romero-Martínez, M. E. Ibáñez-López, A. Acevedo-Merino, and J. L. García-Morales, “Evaluation of ozone treatment for bacterial disinfection of ballast water,” J. Environ. Chem. Eng., vol. 12, no. 1, 2024, doi: 10.1016/j.jece.2023.111656.

J. Xiao, Y. Xu, L. Hu, and H. Wu, “Evaluating the treatment performance of filtration & real-time UV irradiation processes for bacteria and pathogens in fresh ballast water,” Reg. Stud. Mar. Sci., vol. 63, p. 102971, 2023, doi: 10.1016/j.rsma.2023.102971.

S. A. Bailey et al., “First evaluation of ballast water management systems on operational ships for minimizing introductions of nonindigenous zooplankton,” Mar. Pollut. Bull., vol. 182, p. 113947, 2022, doi: 10.1016/j.marpolbul.2022.113947.

A. R. Kim, S. W. Lee, and Y. J. Seo, “How to control and manage vessels’ ballast water: The perspective of Korean shipping companies,” Mar. Policy, vol. 138, no. December 2021, 2022, doi: 10.1016/j.marpol.2022.105007.

Y. C. Chen, P. A. Château, and Y. C. Chang, “Hybrid multiple-criteria decision-making for bulk carriers ballast water management system selection,” Ocean Coast. Manag., vol. 234, no. June 2022, 2023, doi: 10.1016/j.ocecoaman.2022.106456.

H. Karahalios, “The application of the AHP-TOPSIS for evaluating ballast water treatment systems by ship operators,” Transp. Res. Part D Transp. Environ., vol. 52, pp. 172–184, 2017, doi: 10.1016/j.trd.2017.03.001.

N. N. Pereira, F. B. Colombo, M. I. A. Chávez, H. L. Brinati, and M. N. P. Carreño, “Challenges to implementing a ballast water remote monitoring system,” Ocean Coast. Manag., vol. 131, pp. 25–38, 2016, doi: 10.1016/j.ocecoaman.2016.07.008.

ABS, “Best Practices for Operation of Ballast Water Management Systems,” Rep. ABS Ballast Water Manag. Work., 2017, [Online]. Available: https://ww2.eagle.org/content/dam/eagle/publications/reference-report/Marine_BWM_Best_Practices_Report.pdf

IMO, “Annex 5 Resolution MEPC.127(53) Guidelines for Ballast Water Management and Development of Ballast Water Management Plans (G4),” vol. 127, no. July, 2005.

K. Dong, Y. Xu, Q. Wang, X. Liu, J. Xue, and H. Wu, “Study on the effectiveness of membrane separation + N 2 deoxidation process for the treatment of bacteria in ballast water,” Mar. Pollut. Bull., vol. 188, no. February, p. 114652, 2023, doi: 10.1016/j.marpolbul.2023.114652.

A. Ishola and C. A. Kontovas, “Managing Ship ’ s Ballast Water : A Feasibility Assessment of Mobile Port-Based Treatment,” 2022.

M. J. W. Veldhuis, F. Fuhr, J. P. Boon, and C. C. Ten Hallers-tjabbers, “Treatment of Ballast Water ; How to Test a System with a Modular Concept ?,” Environ. Technol., no. November 2014, pp. 37–41, 2010, doi: 10.1080/09593332708618701.

S. M. Mahmud, W. M. N. W. Nik, L. F. Chuah, and A. A. Bakar, “Enhancing Retrofitting Efficiency through 3D Scanning for Selection of Compact Clean Ballast Water Treatment Systems,” vol. 107, no. November, pp. 685–690, 2023, doi: 10.3303/CET23107115.




Copyright (c) 2024 Kapal: Jurnal Ilmu Pengetahuan dan Teknologi Kelautan

Creative Commons License This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

View My Stats

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.