DOI: https://doi.org/10.14710/jksa.28.5.260-266

Adsorption of Methyl Red Dye on Fixed-Bed Column Using Bottom Ash Adsorbent from Palm Oil Mill Waste

1Department of Chemical Engineering, Malikussaleh University, Lhokseumawe, 24351, Indonesia

2Medical Informatics, FKTS, Bumi Persada University, Lhokseumawe, Aceh, Indonesia

Received: 19 Feb 2025; Revised: 19 Jun 2025; Accepted: 24 Jun 2025; Published: 10 Jul 2025.
Open Access Copyright 2025 Jurnal Kimia Sains dan Aplikasi under http://creativecommons.org/licenses/by-sa/4.0.

Citation Format:
Cover Image
Abstract

Methyl red is an azo compound widely applied in the textile industry as a fabric dye. Methyl red is very difficult to decompose because it is stable to light, temperature, and oxidation. One of the simplest and low-cost methods is adsorption. This study aims to determine the characteristics of bottom ash as an adsorbent and analyze the adsorption process with a fixed-bed column system. The research was conducted by varying the flow rate of 5, 10, and 15 L/min, adsorbent bed height of 4, 8, and 12 cm, and contact time of 60, 120, and 180 minutes. The highest removal efficiency, 93%, was achieved at a contact time of 180 minutes, a flow rate of 5 L/min, and a bed height of 12 cm. The physical properties of the bottom ash adsorbent include a pore volume of 0.0032 cm3/g, a specific surface area of 89.801 m2/g, and an average pore size of 58.523 nm. The maximum adsorption capacity was found to be 0.850 mg/g. The adsorption process of methyl red onto bottom ash follows the Langmuir isotherm model.

Fulltext View|Download
Keywords: Adsorption; methyl red; fixed-bed; bottom ash; low-cost

Article Metrics:

Article Info
Section: Research Articles
Language : EN
Recent articles
A Comparative Study of Advanced Oxidation Processes for Pentachlorophenol Degradation Lead Isotope Ratio Optimization using Q-ICP-MS for Volcanic Rocks Synthesis and Antibacterial Testing of Cu(II)-3-Picolylamine Complexes More recent articles
Most cited articles
Skrining Metabolit Sekunder Bakteri Endofit yang Berfungsi sebagai Antidiabetes dari Daun Mimba (Azadirachta Indica) Analisis Pangan: Penentuan Angka Peroksida dan Asam Lemak Bebas pada Minyak Kedelai dengan Variasi Menggoreng Pemanfaatan Karbon Aktif Serbuk Gergaji Kayu Jati untuk Menurunkan Chemical Oxygen Demand (COD) Limbah Cair Industri Tekstil Pengaruh Variasi Jenis Asam terhadap Karakter Nanosilika yang Disintesis dari Abu Sekam Padi Pemanfaatan Montmorillonit Terpilar Al-Cr pada Adsorpsi Zat Warna Rhodamin B dengan Variasi Massa Adsorben dan Waktu Adsorpsi More cited articles
  1. Kayode Adesina Adegoke, Olugbenga Solomon Bello, Dye sequestration using agricultural wastes as adsorbents, Water Resources and Industry, 12, (2015), 8-24 https://doi.org/10.1016/j.wri.2015.09.002
  2. Mohammad M. Hassan, Christopher M. Carr, A critical review on recent advancements of the removal of reactive dyes from dyehouse effluent by ion-exchange adsorbents, Chemosphere, 209, (2018), 201-219 https://doi.org/10.1016/j.chemosphere.2018.06.043
  3. Salma Gul, Mansha Kanwal, Raina Aman Qazi, Hajera Gul, Rozina Khattak, Muhammad Sufaid Khan, Fatima Khitab, Andrey E. Krauklis, Efficient Removal of Methyl Red Dye by Using Bark of Hopbush, Water, 14, 18, (2022), 2831 https://doi.org/10.3390/w14182831
  4. Muhammad Imran, David E. Crowley, Azeem Khalid, Sabir Hussain, Muhammad Waseem Mumtaz, Muhammad Arshad, Microbial biotechnology for decolorization of textile wastewaters, Reviews in Environmental Science and Bio/Technology, 14, 1, (2015), 73-92 https://doi.org/10.1007/s11157-014-9344-4
  5. Hinda Lachheb, Eric Puzenat, Ammar Houas, Mohamed Ksibi, Elimame Elaloui, Chantal Guillard, Jean-Marie Herrmann, Photocatalytic degradation of various types of dyes (Alizarin S, Crocein Orange G, Methyl Red, Congo Red, Methylene Blue) in water by UV-irradiated titania, Applied Catalysis B: Environmental, 39, 1, (2002), 75-90 https://doi.org/10.1016/S0926-3373(02)00078-4
  6. Simran Takkar, Bhawna Tyagi, Naveen Kumar, Taruna Kumari, Khushboo Iqbal, Ajit Varma, Indu Shekhar Thakur, Arti Mishra, Biodegradation of methyl red dye by a novel actinobacterium Zhihengliuella sp. ISTPL4: Kinetic studies, isotherm and biodegradation pathway, Environmental Technology & Innovation, 26, (2022), 102348 https://doi.org/10.1016/j.eti.2022.102348
  7. B. M. Vinoda, M. Vinuth, Y. D. Bodke, J. Manjanna, Photocatalytic degradation of toxic methyl red dye using silica nanoparticles synthesized from rice husk ash, Journal of Environmental and Analytical Toxicology, 5, 6, (2015), 1000336 http://dx.doi.org/10.4172/2161-0525.1000336
  8. Vanitha Katheresan, Jibrail Kansedo, Sie Yon Lau, Efficiency of various recent wastewater dye removal methods: A review, Journal of Environmental Chemical Engineering, 6, 4, (2018), 4676-4697 https://doi.org/10.1016/j.jece.2018.06.060
  9. Mohd Azmier Ahmad, Nur‘Adilah Binti Ahmed, Kayode Adesina Adegoke, Olugbenga Solomon Bello, Sorption studies of methyl red dye removal using lemon grass (Cymbopogon citratus), Chemical Data Collections, 22, (2019), 100249 https://doi.org/10.1016/j.cdc.2019.100249
  10. José Arnaldo S. Costa, Caio M. Paranhos, Mitigation of silica-rich wastes: An alternative to the synthesis eco-friendly silica-based mesoporous materials, Microporous and Mesoporous Materials, 309, (2020), 110570 https://doi.org/10.1016/j.micromeso.2020.110570
  11. Yi Wai Chiang, Karel Ghyselbrecht, Rafael M. Santos, Boudewijn Meesschaert, Johan A. Martens, Synthesis of zeolitic-type adsorbent material from municipal solid waste incinerator bottom ash and its application in heavy metal adsorption, Catalysis Today, 190, 1, (2012), 23-30 https://doi.org/10.1016/j.cattod.2011.11.002
  12. Novi Sylvia, Rozanna Dewi, Ishak Ishak, Miftahul Janni, Melani Annisa Putri, Utilization of Fly Ash Palm Oil Mill Waste as an Adsorbent of Methylene Blue in a Fixed Bed Column System by Using Response Surface Methodology, Jurnal Bahan Alam Terbarukan, 13, 1, (2024), 28-37 https://doi.org/10.15294/jbat.v13i1.50001
  13. Wilson Wei Sheng Ho, Hoon Kiat Ng, Suyin Gan, Development and characterisation of novel heterogeneous palm oil mill boiler ash-based catalysts for biodiesel production, Bioresource Technology, 125, (2012), 158-164 https://doi.org/10.1016/j.biortech.2012.08.099
  14. Jasim Humadi, Amer T. Nawaf, Luay Ahmed Khamees, Yasser A. Abd-Alhussain, Hussain F. Muhsin, Mustafa A. Ahmed, Marwan M. Ahmed, Development of new effective activated carbon supported alkaline adsorbent used for removal phenolic compounds, Communications in Science and Technology, 8, 2, (2023), 164-170 https://dx.doi.org/10.21924/cst
  15. Angga Pratama Herman, Suzana Yusup, Muhammad Shahbaz, David Onoja Patrick, Bottom Ash Characterization and its Catalytic Potential in Biomass Gasification, Procedia Engineering, 148, (2016), 432-436 https://doi.org/10.1016/j.proeng.2016.06.447
  16. Arti Malviya, Dipika Kaur Jaspal, Shraddha Khamparia, Kinetics studies on the adsorption of Methyl Orange and Metanil Yellow onto bottom ash: a comparative account, Water Science and Technology, 80, 10, (2019), 1844-1850 https://doi.org/10.2166/wst.2019.435
  17. Serpil Savcı, Mehmet Mert Uysal, Adsorption of Methylene Blue and Methyl Orange By Using Waste Ash, Süleyman Demirel Üniversitesi Fen Bilimleri Enstitüsü Dergisi, 21, 3, (2017), 831-835
  18. A. P. Wardanu, N. S. Indrasti, Suprihatin, Green Synthesis of Silica Nanoparticles (Si-NPs) from Palm Oil Fuel Ash (POFA) and its Application to Purification Water: A Review, IOP Conference Series: Earth and Environmental Science, 1358, 1, (2024), 012015 https://doi.org/10.1088/1755-1315/1358/1/012015
  19. Novi Sylvia, Fitriani Fitriani, Rozanna Dewi, Rizka Mulyawan, Abrar Muslim, Husni Husin, Yunardi Yunardi, Mutia Reza, Characterization of Bottom Ash Waste Adsorbent from Palm Oil Plant Boiler Burning Process to Adsorb Carbon Dioxide in a Fixed Bed Column, Indonesian Journal of Chemistry, 21, 6, (2021), 1454-1462 https://doi.org/10.22146/ijc.66509
  20. Muhammad Hazwan Hamzah, Muhammad Fitri Ahmad Asri, Hasfalina Che Man, Abdulsalam Mohammed, Prospective Application of Palm Oil Mill Boiler Ash as a Biosorbent: Effect of Microwave Irradiation and Palm Oil Mill Effluent Decolorization by Adsorption, International Journal of Environmental Research and Public Health, 16, 18, (2019), 3453 https://doi.org/10.3390/ijerph16183453
  21. Z. Ioannou, Ch. Karasavvidis, A. Dimirkou, V. Antoniadis, Adsorption of methylene blue and methyl red dyes from aqueous solutions onto modified zeolites, Water Science and Technology, 67, 5, (2013), 1129-1136 https://doi.org/10.2166/wst.2013.672
  22. Paul Egwuonwu DIM, Adsorption of methyl red and methyl orange using different tree bark powder, SAVAP International, 4, 1, (2013), 330-338
  23. Denga Ramutshatsha-Makhwedzha, Avhafunani Mavhungu, Mapula Lucey Moropeng, Richard Mbaya, Activated carbon derived from waste orange and lemon peels for the adsorption of methyl orange and methylene blue dyes from wastewater, Heliyon, 8, 8, (2022), e09930 https://doi.org/10.1016/j.heliyon.2022.e09930
  24. Khaled Mahmoudi, Khaled Hosni, Noureddine Hamdi, Ezzeddine Srasra, Kinetics and equilibrium studies on removal of methylene blue and methyl orange by adsorption onto activated carbon prepared from date pits-A comparative study, Korean Journal of Chemical Engineering, 32, 2, (2015), 274-283 https://doi.org/10.1007/s11814-014-0216-y
  25. Sunil Rajoriya, Virendra Kumar Saharan, Avdesh Singh Pundir, Mohit Nigam, Kuldeep Roy, Adsorption of methyl red dye from aqueous solution onto eggshell waste material: Kinetics, isotherms and thermodynamic studies, Current Research in Green and Sustainable Chemistry, 4, (2021), 100180 https://doi.org/10.1016/j.crgsc.2021.100180
  26. Tawfik A. Saleh, Akram A. Al-Absi, Kinetics, isotherms and thermodynamic evaluation of amine functionalized magnetic carbon for methyl red removal from aqueous solutions, Journal of Molecular Liquids, 248, (2017), 577-585 https://doi.org/10.1016/j.molliq.2017.10.064
  27. Robert Wolski, Aleksandra Bazan-Wozniak, Robert Pietrzak, Adsorption of Methyl Red and Methylene Blue on Carbon Bioadsorbents Obtained from Biogas Plant Waste Materials, Molecules, 28, 18, (2023), 6712 https://doi.org/10.3390/molecules28186712
  28. Kingsley O. Iwuozor, Joshua O. Ighalo, Ebuka Chizitere Emenike, Lawal Adewale Ogunfowora, Chinenye Adaobi Igwegbe, Adsorption of methyl orange: A review on adsorbent performance, Current Research in Green and Sustainable Chemistry, 4, (2021), 100179 https://doi.org/10.1016/j.crgsc.2021.100179
  29. Mohd Azmier Ahmad, Norhidayah Ahmad, Olugbenga Solomon Bello, Modified durian seed as adsorbent for the removal of methyl red dye from aqueous solutions, Applied Water Science, 5, 4, (2015), 407-423 https://doi.org/10.1007/s13201-014-0208-4
  30. Ying-Hong Guan, Jin Chen, Li-Jun Chen, Xin-Xin Jiang, Qiang Fu, Comparison of UV/H2O2, UV/PMS, and UV/PDS in Destruction of Different Reactivity Compounds and Formation of Bromate and Chlorate, Frontiers in Chemistry, 8, (2020), https://doi.org/10.3389/fchem.2020.581198
  31. Ruiyang Xiao, Lei He, Zonghao Luo, Richard Spinney, Zongsu Wei, Dionysios D. Dionysiou, Feiping Zhao, An experimental and theoretical study on the degradation of clonidine by hydroxyl and sulfate radicals, Science of The Total Environment, 710, (2020), 136333 https://doi.org/10.1016/j.scitotenv.2019.136333
  32. J. Rodríguez-Chueca, E. Laski, C. García-Cañibano, M. J. Martín de Vidales, Á Encinas, B. Kuch, J. Marugán, Micropollutants removal by full-scale UV-C/sulfate radical based Advanced Oxidation Processes, Science of The Total Environment, 630, (2018), 1216-1225 https://doi.org/10.1016/j.scitotenv.2018.02.279
  33. Pengfei Gan, Yichun Sun, Yunyi Li, Wen Liu, Jiangyu Ye, Meiping Tong, Jialiang Liang, The degradation of municipal solid waste incineration leachate by UV/persulfate and UV/H2O2 processes: The different selectivity of SO4•- and •OH, Chemosphere, 311, (2023), 137009 https://doi.org/10.1016/j.chemosphere.2022.137009
  34. George Z. Kyzas, Nezamaddin Mengelizadeh, Morteza khodadadi Saloot, Samaneh Mohebi, Davoud Balarak, Sonochemical degradation of ciprofloxacin by hydrogen peroxide and persulfate activated by ultrasound and ferrous ions, Colloids and Surfaces A: Physicochemical and Engineering Aspects, 642, (2022), 128627 https://doi.org/10.1016/j.colsurfa.2022.128627
  35. Jongbok Choi, Dukyoung Lee, Younggyu Son, Ultrasonic activation of persulfate for removal of aqueous pollutants: cavitational versus thermal mechanisms, Current Opinion in Chemical Engineering, 48, (2025), 101136 https://doi.org/10.1016/j.coche.2025.101136
  36. Xiuneng Zhu, Jie Qiu, Yexing Wang, Yulin Tang, Yongji Zhang, Effective Degradation of 1,4-Dioxane by UV-Activated Persulfate: Mechanisms, Parameters and Environmental Impacts, Water, 16, 9, (2024), 1281 https://doi.org/10.3390/w16091281
  37. David B. Miklos, Christian Remy, Martin Jekel, Karl G. Linden, Jörg E. Drewes, Uwe Hübner, Evaluation of advanced oxidation processes for water and wastewater treatment – A critical review, Water Research, 139, (2018), 118-131 https://doi.org/10.1016/j.watres.2018.03.042
  38. Marlo S. Morgan, Paul F. Van Trieste, Stephanie M. Garlick, Martin J. Mahon, Allan L. Smith, Ultraviolet molar absorptivities of aqueous hydrogen peroxide and hydroperoxyl ion, Analytica Chimica Acta, 215, (1988), 325-329 https://doi.org/10.1016/S0003-2670(00)85294-0
  39. Jaesang Lee, Urs von Gunten, Jae-Hong Kim, Persulfate-Based Advanced Oxidation: Critical Assessment of Opportunities and Roadblocks, Environmental Science & Technology, 54, 6, (2020), 3064-3081 https://doi.org/10.1021/acs.est.9b07082
  40. Kirill Fedorov, Kumaravel Dinesh, Xun Sun, Reza Darvishi Cheshmeh Soltani, Zhaohui Wang, Shirish Sonawane, Grzegorz Boczkaj, Synergistic effects of hybrid advanced oxidation processes (AOPs) based on hydrodynamic cavitation phenomenon – A review, Chemical Engineering Journal, 432, (2022), 134191 https://doi.org/10.1016/j.cej.2021.134191
  41. Ritesh Patidar, Vimal Chandra Srivastava, Mechanistic and kinetic insights of synergistic mineralization of ofloxacin using a sono-photo hybrid process, Chemical Engineering Journal, 403, (2021), 125736 https://doi.org/10.1016/j.cej.2020.125736
  42. Seungmin Na, Yun-Gyong Ahn, Mingcan Cui, Jeehyeong Khim, Significant diethyl phthalate (DEP) degradation by combined advanced oxidation process in aqueous solution, Journal of Environmental Management, 101, (2012), 104-110 https://doi.org/10.1016/j.jenvman.2012.01.028
  43. Oualid Hamdaoui, Emmanuel Naffrechoux, Sonochemical and photosonochemical degradation of 4-chlorophenol in aqueous media, Ultrasonics Sonochemistry, 15, 6, (2008), 981-987 https://doi.org/10.1016/j.ultsonch.2008.03.011
  44. Sanzeeda Baig Shuchi, Md Burhan Kabir Suhan, Sufian Bin Humayun, Muhammad Enamul Haque, Md Shahinoor Islam, Heat-activated potassium persulfate treatment of Sudan Black B dye: Degradation kinetic and thermodynamic studies, Journal of Water Process Engineering, 39, (2021), 101690 https://doi.org/10.1016/j.jwpe.2020.101690
  45. H. C. Yap, Y. L. Pang, S. Lim, A. Z. Abdullah, H. C. Ong, C. H. Wu, A comprehensive review on state-of-the-art photo-, sono-, and sonophotocatalytic treatments to degrade emerging contaminants, International Journal of Environmental Science and Technology, 16, 1, (2019), 601-628 https://doi.org/10.1007/s13762-018-1961-y
  46. Gholam Hossein Safari, Simin Nasseri, Amir Hossein Mahvi, Kamyar Yaghmaeian, Ramin Nabizadeh, Mahmood Alimohammadi, Optimization of sonochemical degradation of tetracycline in aqueous solution using sono-activated persulfate process, Journal of Environmental Health Science and Engineering, 13, (2015), 76 https://doi.org/10.1186/s40201-015-0234-7
  47. Linning Yin, Junyan Wei, Yumeng Qi, Zhengnan Tu, Ruijuan Qu, Chao Yan, Zunyao Wang, Feng Zhu, Degradation of pentachlorophenol in peroxymonosulfate/heat system: Kinetics, mechanism, and theoretical calculations, Chemical Engineering Journal, 434, (2022), 134736 https://doi.org/10.1016/j.cej.2022.134736
  48. Xiaofei Xue, Khalil Hanna, Mustapha Abdelmoula, Nansheng Deng, Adsorption and oxidation of PCP on the surface of magnetite: Kinetic experiments and spectroscopic investigations, Applied Catalysis B: Environmental, 89, 3, (2009), 432-440 https://doi.org/10.1016/j.apcatb.2008.12.024
  49. James R. Bolton, Keith G. Bircher, William Tumas, Chadwick A. Tolman, Figures-of-merit for the technical development and application of advanced oxidation technologies for both electric- and solar-driven systems (IUPAC Technical Report), Pure and Applied Chemistry, 73, 4, (2001), 627-637 https://doi.org/10.1351/pac200173040627
  50. Mohammad A. Behnajady, Behrouz Vahid, Nasser Modirshahla, Mohammad Shokri, Evaluation of electrical energy per order (EEO) with kinetic modeling on the removal of Malachite Green by US/UV/H2O2 process, Desalination, 249, 1, (2009), 99-103 https://doi.org/10.1016/j.desal.2008.07.025
  51. Kaiheng Guo, Zihao Wu, Shuwen Yan, Bo Yao, Weihua Song, Zhechao Hua, Xuewen Zhang, Xiujuan Kong, Xuchun Li, Jingyun Fang, Comparison of the UV/chlorine and UV/H2O2 processes in the degradation of PPCPs in simulated drinking water and wastewater: Kinetics, radical mechanism and energy requirements, Water Research, 147, (2018), 184-194 https://doi.org/10.1016/j.watres.2018.08.048
  52. Menghong Gao, Shuili Yu, Li'an Hou, Xingli Ji, Rongsheng Ning, Ying Xu, Lei Li, Treatment of emerging pyrrolizidine alkaloids in drinking water by UV/persulfate process: Kinetics, energy efficiency and degradation pathway, Chemical Engineering Journal, 490, (2024), 151852 https://doi.org/10.1016/j.cej.2024.151852

Last update:

No citation recorded.

Last update: 2025-07-12 01:17:43

No citation recorded.