DOI: https://doi.org/10.14710/ijred.2021.31982

Investigation of Process Parameters Influence on Municipal Solid Waste Gasification with CO2 Capture via Process Simulation Approach

Department of Chemical Engineering, Universitas Islam Indonesia, Indonesia

Received: 30 Jul 2020; Revised: 26 Aug 2020; Accepted: 3 Sep 2020; Available online: 11 Sep 2020; Published: 1 Feb 2021.
Editor(s): H. Hadiyanto
Open Access Copyright (c) 2021 The Authors. Published by Centre of Biomass and Renewable Energy (CBIORE)
Creative Commons License This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

Citation Format:
Abstract

Integration of gasification with CO2 capture using CaO sorbent is proposed as an alternative treatment to convert municipal solid waste (MSW) into energy. Aspen Plus process simulator was employed to study the process. Two models were built to represent the non-sorbent and the sorbent-enabled MSW gasification. The model validation against available experimental data shows high accuracy of the simulation result. The effect of CO2 capture using CaO sorbent on the syngas composition and lower heating value (LHV) was observed by comparing the two models, and sensitivity analysis was performed on both models. Several process parameters affecting the syngas composition and LHV were investigated, including CaO/MSW ratio, temperature, equivalence ratio, and steam/MSW ratio. The addition of CaO sorbent for CO2 capture was found to successfully reduce the CO2 content in the syngas, increase the H2 composition, and improve the syngas LHV at the temperature below 750 oC. The maximum H2 composition of 56.67% was obtained from the sorbent-enabled gasification. It was found that increasing equivalence ratio leads to a higher H2 concentration and syngas LHV. Raising steam/MSW ratio also increases the H2 production, but also reduces the LHV of the syngas. Observation of the temperature effect found the highest H2 production at 650 oC for both non-sorbent and sorbent-enabled gasification. 

Fulltext View|Download
Keywords: CaO sorption; CO2 capture; gasification; municipal solid waste; syngas
Funding: Directorate of Research and Community Development (DPPM) Universitas Islam Indonesia

Article Metrics:

Article Info
Section: Original Research Article
Language : EN
Recent articles
The Utilization of Water Hyacinth for Biogas Production in a Plug Flow Anaerobic Digester Biofuels Production from Catalytic Cracking of Palm Oil Using Modified HY Zeolite Catalysts over A Continuous Fixed Bed Catalytic Reactor Investigation of Process Parameters Influence on Municipal Solid Waste Gasification with CO2 Capture via Process Simulation Approach Preparation of Anode Material for Lithium Battery from Activated Carbon The Impact of Hydraulic Retention Time on the Biomethane Production from Palm Oil Mill Effluent (POME) in Two-Stage Anaerobic Fluidized Bed Reactor More recent articles
Most cited articles
The Costs of Producing Biodiesel from Microalgae in the Asia-Pacific Region Effect of hydrothermal treatment temperature on the properties of sewage sludge derived solid fuel Electricity Production from Wind Energy By Piezoelectric Material Integration of 5G Technologies in Smart Grid Communication-A Short Survey Woodfuel in Rwanda: Impact on Energy, Poverty, Environment and Policy Instruments analysis More cited articles
  1. Acharya, B., Dutta, A. & Basu, P. (2010). An investigation into steam gasification of biomass for hydrogen enriched gas production in presence of CaO. International journal of hydrogen energy, 35, 1582-1589. https://doi.org/10.1016/j.ijhydene.2009.11.109
  2. Adi, A. C., Lasnawatin, F., Prananto, A., Suzanti, V., Anutomo, I., Anggreani, D. & Yuanningrat, H. (2019). Handbook of Energy and Economic Statistics of Indonesia 2018. Ministry of Energy and Mineral Resources Republic of Indonesia
  3. Al-Salem, S., Lettieri, P. & Baeyens, J. (2010). The valorization of plastic solid waste (PSW) by primary to quaternary routes: From re-use to energy and chemicals. Progress in Energy and Combustion Science, 36, 103-129. https://doi.org/10.1016/j.pecs.2009.09.001
  4. Al Amoodi, N., Kannan, P., Al Shoaibi, A. & Srinivasakannan, C. (2013). Aspen Plus simulation of polyethylene gasification under equilibrium conditions. Chemical Engineering Communications, 200, 977-992. https://doi.org/10.1080/00986445.2012.715108
  5. Autret, E., Berthier, F., Luszezanec, A. & Nicolas, F. (2007). Incineration of municipal and assimilated wastes in France: Assessment of latest energy and material recovery performances. Journal of hazardous materials, 139, 569-574. https://doi.org/10.1016/j.jhazmat.2006.02.065
  6. Begum, S., Rasul, M. & Akbar, D. (2014). A numerical investigation of municipal solid waste gasification using aspen plus. Procedia engineering, 90, 710-717. https://doi.org/10.1016/j.proeng.2014.11.800
  7. Bunma, T. & Kuchonthara, P. (2018). Synergistic study between CaO and MgO sorbents for hydrogen rich gas production from the pyrolysis-gasification of sugarcane leaves. Process Safety and Environmental Protection, 118, 188-194. https://doi.org/10.1016/j.psep.2018.06.034
  8. Chen, C., Jin, Y.-Q., Yan, J.-H. & Chi, Y. (2013). Simulation of municipal solid waste gasification in two different types of fixed bed reactors. Fuel, 103, 58-63. https://doi.org/10.1016/j.fuel.2011.06.075
  9. Chen, H. & Wang, L. (2016). Technologies for biochemical conversion of biomass, Academic Press. https://doi.org/10.1016/B978-0-12-802417-1.00003-X
  10. Chen, S., Sun, Z., Zhang, Q., Hu, J. & Xiang, W. (2017). Steam gasification of sewage sludge with CaO as CO2 sorbent for hydrogen-rich syngas production. Biomass and bioenergy, 107, 52-62. https://doi.org/10.1016/j.biombioe.2017.09.009
  11. Consonni, S. & Viganò, F. (2012). Waste gasification vs. conventional Waste-To-Energy: A comparative evaluation of two commercial technologies. Waste management, 32, 653-666. https://doi.org/10.1016/j.wasman.2011.12.019
  12. Dong, J., Tang, Y., Nzihou, A., Chi, Y., Weiss-Hortala, E., Ni, M. & Zhou, Z. (2018). Comparison of waste-to-energy technologies of gasification and incineration using life cycle assessment: Case studies in Finland, France and China. Journal of Cleaner Production, 203, 287-300. https://doi.org/10.1016/j.jclepro.2018.08.139
  13. Doranehgard, M. H., Samadyar, H., Mesbah, M., Haratipour, P. & Samiezade, S. (2017). High-purity hydrogen production with in situ CO2 capture based on biomass gasification. Fuel, 202, 29-35. https://doi.org/10.1016/j.fuel.2017.04.014
  14. Dos Santos, R. G. & Alencar, A. C. (2020). Biomass-derived syngas production via gasification process and its catalytic conversion into fuels by Fischer Tropsch synthesis: a review. International Journal of Hydrogen Energy, 45, 18114-18132. https://doi.org/10.1016/j.ijhydene.2019.07.133
  15. Eggleston, S., Buendia, L., Miwa, K., Ngara, T. & Tanabe, K. (2006). 2006 IPCC guidelines for national greenhouse gas inventories, Institute for Global Environmental Strategies Hayama, Japan
  16. Gao, W., Yan, L., Tahmoures, M. & Asgari Safdar, A. H. (2018). Hydrogen Production from Co‐Gasification of Coal and Biomass in the Presence of CaO as a Sorbent. Chemical Engineering & Technology, 41, 447-453. https://doi.org/10.1002/ceat.201700272
  17. Hanak, D. P., Anthony, E. J. & Manovic, V. (2015). A review of developments in pilot-plant testing and modelling of calcium looping process for CO 2 capture from power generation systems. Energy & Environmental Science, 8, 2199-2249. https://doi.org/10.1039/C5EE01228G
  18. Hosseini, S. E. & Wahid, M. A. (2016). Hydrogen production from renewable and sustainable energy resources: promising green energy carrier for clean development. Renewable and Sustainable Energy Reviews, 57, 850-866. https://doi.org/10.1016/j.rser.2015.12.112
  19. Hu, M., Guo, D., Ma, C., Hu, Z., Zhang, B., Xiao, B., Luo, S. & Wang, J. (2015). Hydrogen-rich gas production by the gasification of wet MSW (municipal solid waste) coupled with carbon dioxide capture. Energy, 90, 857-863. https://doi.org/10.1016/j.energy.2015.07.122
  20. Jingxia, Y. (2018). Municipal solid waste (MSW)-to-energy in China: challenges and cost analysis. Energy Sources, Part B: Economics, Planning, and Policy, 13, 116-120. https://doi.org/10.1080/15567249.2017.1391895
  21. Kapdan, I. K. & Kargi, F. (2006). Bio-hydrogen production from waste materials. Enzyme and microbial technology, 38, 569-582. https://doi.org/10.1016/j.enzmictec.2005.09.015
  22. Khalil, M., Berawi, M. A., Heryanto, R. & Rizalie, A. (2019). Waste to energy technology: The potential of sustainable biogas production from animal waste in Indonesia. Renewable and Sustainable Energy Reviews, 105, 323-331. https://doi.org/10.1016/j.rser.2019.02.011
  23. Khuriati, A., Purwanto, P., Huboyo, H. S., Suryono, S. & Putro, A. B. (2018). Application of aspen plus for municipal solid waste plasma gasification simulation: case study of Jatibarang Landfill in Semarang Indonesia. Journal of Physics: Conference Series, 012006. https://doi.org/10.1088/1742-6596/1025/1/012006
  24. Korai, M. S., Mahar, R. B. & Uqaili, M. A. (2016). Optimization of waste to energy routes through biochemical and thermochemical treatment options of municipal solid waste in Hyderabad, Pakistan. Energy Conversion and Management, 124, 333-343. https://doi.org/10.1016/j.enconman.2016.07.032
  25. Li, B., Yang, H., Wei, L., Shao, J., Wang, X. & Chen, H. (2017). Absorption-enhanced steam gasification of biomass for hydrogen production: Effects of calcium-based absorbents and NiO-based catalysts on corn stalk pyrolysis-gasification. International Journal of Hydrogen Energy, 42, 5840-5848. https://doi.org/10.1016/j.ijhydene.2016.12.031
  26. Lin, S., Kiga, T., Wang, Y. & Nakayama, K. (2011). Energy analysis of CaCO3 calcination with CO2 capture. Energy Procedia, 4, 356-361. https://doi.org/10.1016/j.egypro.2011.01.062
  27. Luo, S., Zhou, Y. & Yi, C. (2012). Syngas production by catalytic steam gasification of municipal solid waste in fixed-bed reactor. Energy, 44, 391-395. https://doi.org/10.1016/j.energy.2012.06.016
  28. Mahishi, M. R. & Goswami, D. (2007). An experimental study of hydrogen production by gasification of biomass in the presence of a CO2 sorbent. International Journal of Hydrogen Energy, 32, 2803-2808. https://doi.org/10.1016/j.ijhydene.2007.03.030
  29. Manovic, V. & Anthony, E. J. (2010). Lime-based sorbents for high-temperature CO2 capture-a review of sorbent modification methods. International journal of environmental research and public health, 7, 3129-3140. https://doi.org/10.3390/ijerph7083129
  30. Mishra, R. K. & Mohanty, K. (2018). An Overview of Techno-economic Analysis and Life-Cycle Assessment of Thermochemical Conversion of Lignocellulosic Biomass. Recent Advancements in Biofuels and Bioenergy Utilization, 363-402. https://doi.org/10.1007/978-981-13-1307-3_15
  31. Moghadam, R. A., Yusup, S., Uemura, Y., Chin, B. L. F., Lam, H. L. & Al Shoaibi, A. (2014). Syngas production from palm kernel shell and polyethylene waste blend in fluidized bed catalytic steam co-gasification process. Energy, 75, 40-44. https://doi.org/10.1016/j.energy.2014.04.062
  32. Molino, A., Larocca, V., Chianese, S. & Musmarra, D. (2018). Biofuels production by biomass gasification: A review. Energies, 11, 811. https://doi.org/10.3390/en11040811
  33. Niu, M., Huang, Y., Jin, B. & Wang, X. (2013). Simulation of syngas production from municipal solid waste gasification in a bubbling fluidized bed using Aspen Plus. Industrial & Engineering Chemistry Research, 52, 14768-14775. https://doi.org/10.1021/ie400026b
  34. Parthasarathy, P. & Narayanan, K. S. (2014). Hydrogen production from steam gasification of biomass: influence of process parameters on hydrogen yield-a review. Renewable energy, 66, 570-579. https://doi.org/10.1016/j.renene.2013.12.025
  35. Peng, W., Wang, L., Mirzaee, M., Ahmadi, H., Esfahani, M. & Fremaux, S. (2017). Hydrogen and syngas production by catalytic biomass gasification. Energy Conversion and Management, 135, 270-273. https://doi.org/10.1016/j.enconman.2016.12.056
  36. Putro, F. A., Pranolo, S. H., Waluyo, J. & Setyawan, A. (2020). Thermodynamic Study of Palm Kernel Shell Gasification for Aggregate Heating in an Asphalt Mixing Plant. International Journal of Renewable Energy Development, 9, 311-317. https://doi.org/10.14710/ijred.9.2.311-317
  37. Ramzan, N., Ashraf, A., Naveed, S. & Malik, A. (2011). Simulation of hybrid biomass gasification using Aspen plus: A comparative performance analysis for food, municipal solid and poultry waste. Biomass and Bioenergy, 35, 3962-3969. https://doi.org/10.1016/j.biombioe.2011.06.005
  38. Rupesh, S., Muraleedharan, C. & Arun, P. (2016). ASPEN plus modelling of air-steam gasification of biomass with sorbent enabled CO2 capture. Resource-efficient technologies, 2, 94-103. https://doi.org/10.1016/j.reffit.2016.07.002
  39. Salkuyeh, Y. K., Saville, B. A. & Maclean, H. L. (2018). Techno-economic analysis and life cycle assessment of hydrogen production from different biomass gasification processes. International Journal of Hydrogen Energy, 43, 9514-9528. https://doi.org/10.1016/j.ijhydene.2018.04.024
  40. Shahbaz, M., Yusup, S., Inayat, A., Patrick, D. O., Ammar, M. & Pratama, A. (2017). Cleaner production of hydrogen and syngas from catalytic steam palm kernel shell gasification using CaO sorbent and coal bottom ash as a catalyst. Energy & Fuels, 31, 13824-13833. https://doi.org/10.1021/acs.energyfuels.7b03237
  41. Shayan, E., Zare, V. & Mirzaee, I. (2018). Hydrogen production from biomass gasification; a theoretical comparison of using different gasification agents. Energy Conversion and management, 159, 30-41. https://doi.org/10.1016/j.enconman.2017.12.096
  42. Sikarwar, V. S., Zhao, M., Clough, P., Yao, J., Zhong, X., Memon, M. Z., Shah, N., Anthony, E. J. & Fennell, P. S. (2016). An overview of advances in biomass gasification. Energy & Environmental Science, 9, 2939-2977. https://doi.org/10.1039/C6EE00935B
  43. Sittisun, P., Tippayawong, N. & Shimpalee, S. (2019). Gasification of pelletized corn residues with oxygen enriched air and steam. International Journal of Renewable Energy Development, 8, 215. https://doi.org/10.14710/ijred.8.3.215-224
  44. Sudibyo, H., Majid, A.I., Pradana, Y.S., Budhijanto, W., Deendarlianto, and Budiman, A. (2017). Technological evaluation of municipal solid waste management system in Indonesia. Energy Procedia, 105, 263-269. https://doi.org/10.1016/j.egypro.2017.03.312
  45. Sutijastoto, A. R., Suharyati, I. R., Kurniawan, F., Kurniawan, A., Suzanti, V. & Ajiwihanto, N. (2010). Handbook of energy & economic statistics of Indonesia 2009. Ministry of energy and mineral resources republic Indonesia
  46. Toonssen, R., Sollai, S., Aravind, P., Woudstra, N. & Verkooijen, A. H. (2011). Alternative system designs of biomass gasification SOFC/GT hybrid systems. International journal of hydrogen energy, 36, 10414-10425. https://doi.org/10.1016/j.ijhydene.2010.06.069
  47. Zhao, H. & Wang, J. (2018). Chemical-looping combustion of plastic wastes for in situ inhibition of dioxins. Combustion and Flame, 191, 9-18. https://doi.org/10.1016/j.combustflame.2017.12.026
  48. Zhou, L., Yang, Z., Tang, A., Huang, H., Wei, D., Yu, E. & Lu, W. (2019). Steam-gasification of biomass with CaO as catalyst for hydrogen-rich syngas production. Journal of the Energy Institute, 92, 1641-1646. https://doi.org/10.1016/j.joei.2019.01.010
  49. Zuberi, M. J. S. & Ali, S. F. (2015). Greenhouse effect reduction by recovering energy from waste landfills in Pakistan. Renewable and Sustainable Energy Reviews, 44, 117-131. https://doi.org/10.1016/j.rser.2014.12.028

Last update:

  1. Gasification of refuse-derived fuel from municipal solid waste for energy production: a review

    Yan Yang, Rock Keey Liew, Arularasu Muthaliar Tamothran, Shin Ying Foong, Peter Nai Yuh Yek, Poh Wai Chia, Thuan Van Tran, Wanxi Peng, Su Shiung Lam. Environmental Chemistry Letters, 19 (3), 2021. doi: 10.1007/s10311-020-01177-5

  2. Improving the prediction of biochar production from various biomass sources through the implementation of eXplainable machine learning approaches

    Van Giao Nguyen, Prabhakar Sharma, Ümit Ağbulut, Huu Son Le, Dao Nam Cao, Marek Dzida, Sameh M. Osman, Huu Cuong Le, Viet Dung Tran. International Journal of Green Energy, 2024. doi: 10.1080/15435075.2024.2326076

  3. Solid waste management by RDF production from landfilled waste to renewable fuel of Nonthaburi

    Udorn Rahotharn, Maneerat Khemkhao, Prangtip Rittichote Kaewpengkrow. International Journal of Renewable Energy Development, 12 (5), 2023. doi: 10.14710/ijred.2023.52956

  4. Aspen plus simulation model of municipal solid waste gasification of metropolitan city for syngas production

    Muzaffar Mehdi, Syed Ali Ammar Taqvi, Asif Ahmed Shaikh, Saad Khan, Salman Raza Naqvi, Muhammad Shahbaz, Dagmar Juchelková. Fuel, 344 , 2023. doi: 10.1016/j.fuel.2023.128128

  5. A general model for air gasification of heterogenous municipal solid waste

    Giovanni Biancini, Ramin Moradi, Luca Cioccolanti, Barbara Marchetti, Matteo Moglie, Luca Del Zotto. Energy Conversion and Management, 278 , 2023. doi: 10.1016/j.enconman.2023.116749

  6. Negative carbon dioxide gas power plant integrated with gasification of sewage sludge

    Paweł Ziółkowski, Kamil Stasiak, Milad Amiri, Dariusz Mikielewicz. Energy, 262 , 2023. doi: 10.1016/j.energy.2022.125496

  7. Potential of renewable agricultural wastes in the smart and sustainable steelmaking process

    Ishani Shukla. Journal of Cleaner Production, 370 , 2022. doi: 10.1016/j.jclepro.2022.133422

  8. Plastic waste/chickpea straw-to-fuels and power through co-gasification in a novel zero-emission system by CO2 capturing and utilization

    Parisa Mojaver, Shahram Khalilarya, Ata Chitsaz, Samad Jafarmadar. Fuel, 348 , 2023. doi: 10.1016/j.fuel.2023.128490

  9. Simulation and experimental study of refuse-derived fuel gasification in an updraft gasifier

    Thanh Xuan Nguyen-Thi, Thi Minh Tu Bui, Van Ga Bui. International Journal of Renewable Energy Development, 12 (3), 2023. doi: 10.14710/ijred.2023.53994

  10. Co-gasification of refuse-derived fuels and bituminous coal with oxygen/steam blend to hydrogen rich gas

    Adam Smoliński, Karolina Wojtacha-Rychter, Magdalena Król, Małgorzata Magdziarczyk, Jarosław Polański, Natalia Howaniec. Energy, 254 , 2022. doi: 10.1016/j.energy.2022.124210

  11. Waste to energy: An experimental study on hydrogen production from food waste gasification

    Ashok Kumar Koshariya, M. Sivaram Krishnan, S. Jaisankar, Ganesh Babu Loganathan, T. Sathish, Ümit Ağbulut, R. Saravanan, Le Thanh Tuan, Nguyen Dang Khoa Pham. International Journal of Hydrogen Energy, 54 , 2024. doi: 10.1016/j.ijhydene.2023.05.221

  12. Conversion of municipals waste into syngas and methanol via steam gasification using CaO as sorbent: An Aspen Plus modelling

    Arshid Mahmood Ali, Muhammad Shahbaz, Muddasser Inayat, Khurram Shahzad, Abdulrahim Ahmad Al-Zahrani, Aishah Binti Mahpudz. Fuel, 349 , 2023. doi: 10.1016/j.fuel.2023.128640

  13. Ce/Pumice and Ni/Pumice as heterogeneous catalysts for syngas production from biomass gasification

    S. Señorans, J. R-Díaz, D. Escalante, L.A. González, L. Díaz. Waste Management, 166 , 2023. doi: 10.1016/j.wasman.2023.05.017

Last update: 2024-04-23 14:34:35

No citation recorded.