DOI: https://doi.org/10.14710/ijred.7.3.205-212

Prosopis juliflora pods mash for biofuel energy production: Implication for managing invasive species through utilization

1Department of Land Resource Management and Environmental Protection, College of Dryland Agriculture and Natural Resources, Mekelle University, Ethiopia

2Department of Land Resource Management and Environmental Protection, College of Dryland Agriculture and Natural Resources, Mekelle University,, Ethiopia

3Department of Chemistry, College of Natural and Computational Sciences, Mekelle University, Ethiopia

Published: 15 Dec 2018.
Editor(s): H Hadiyanto

Citation Format:
Abstract

Fuels obtained from renewable resources have merited a lot of enthusiasm amid the previous decades mostly because of worries about fossil fuel depletion and climate change. The aim of this study was to investigate the potential of Prosopis juliflora pods mash for bio-ethanol production and its hydrolysis solid waste for solid fuel. Parameters such as acid concentration (0.5 - 3 molar), hydrolysis times (5-30 min), fermentation times (6-72h), fermentation temperature (25 OC - 40 OC) and pH (4-8) on bio-ethanol production using Saccharomyces cerevisiae yeast were evaluated. Results show that the content of sugar increases as the acid concentration (H2SO4) increased up to 1 molar and decreases beyond 1 molar.  A maximum sugar content of 96.13 %v/v was obtained at 1 molar of H2SO4 concentration. The optimum conditions for bio-ethanol production were found at 1 molar of H2SO4 concentration (4.2 %v/v), 48 h fermentation time (5.1%v/v), 20 min hydrolysis time (5.57 %v/v), 30 OC fermentation temperature (5.57 %v/v) and pH 5 (6.01 %v/v). Under these optimum conditions, the maximum yield of bio-ethanol (6.01%v/v) was obtained. Furthermore, the solid waste remaining after bio-ethanol production was evaluated for solid fuel application (18.22 MJ/kg). Hence, the results show that Prosopis juliflora pods mash has the potential to produce bio-ethanol. The preliminary analysis of solid waste after hydrolysis suggests the possibility to use it as a solid fuel, implying its potential for alleviating major disposal problems.

Article History: Received March 24th 2018 ; Received in revised form September 15th 2018; Accepted October 1st 2018; Available online

How to Cite This Article: Haile, M., Hishe, H. and Gebremedhin, D. (2018) Prosopis juliflora Pods Mash for Biofuel Energy Production: Implication for Managing Invasive Species through Utilization. International Journal of Renewable Energy Development, 7(3), 205-212.

https://doi.org/10.14710/ijred.7.3.205-212

 

Fulltext View|Download
Keywords: Prosopis juliflora pods mash, bioethanol, hydrolysis, fermentation, Saccharomyces cerevisiae, solid fuel
Funding: Mekelle university recurrent budget

Article Metrics:

Article Info
Section: Original Research Article
Language : EN
Recent articles
Prosopis juliflora pods mash for biofuel energy production: Implication for managing invasive species through utilization Comparison between conventional design and cathode gas recirculation design of a direct-syngas solid oxide fuel cell–gas turbine hybrid systems part II: Effect of temperature difference at the fuel cell stack Aerodynamic analysis of backward swept in HAWT rotor blades using CFD More recent articles
Most cited articles
Design, Analysis and Optimization of a Solar Dish/Stirling System Bioelectricity Generation From Single-Chamber Microbial Fuel Cells With Various Local Soil Media and Green Bean Sprouts as Nutrient Biodiesel Production From the Microalgae Nannochloropsis by Microwave Using CaO and MgO Catalysts Tin (II) Chloride Catalyzed Esterification of High FFA Jatropha Oil: Experimental and Kinetics Study Enhancement and Optimization Mechanisms of Biogas Production for Rural Household Energy in Developing Countries: A review More cited articles
  1. Abebe, T. (1994) Growth-performance of some multi-purpose trees and shrubs in the semiarid areas of southern Ethiopia. Agroforestry Systems, 26, 237-248
  2. Admasu, D. (2008) Invasive plants and food security: The case of Prosopis juliflora in the Afar region of Ethiopia. FARM-Africa, IUCN, 1–13
  3. Akpan, U.G., Alhakim, A. A. & Ijah, U. J.J. (2008) Production of ethanol Fuel from Organic and Food Wastes. Leonardo Electronic Journal of Practices and Technologies ISSN 1583-1078, 1-11
  4. Ayele, K., Mesfin, R. & Araya, A. (2012) Potential of Bioethanol Production and Optimization Test from Agricultural Waste; the Case of Wet Coffee Processing Waste (Pulp). International Journal of renewable energy research, 2 (3)
  5. Bravo, L., Grados, N. & Saura-calixto, F. (1994) Composition and potential uses of mesquite pods (Prosopis pallida L) - comparison with carob pods (Ceratonia siliqua L). Journal of the Science of Food and Agriculture 65, 303-306
  6. Choge, S.K., Pasiecznik, N.M., Harvey, M., Wright, J., Awan, S.Z., & Harris, P.J. (2007) Prosopis pods as human food, with special reference to Kenya. Nairobi, Kenya Forest Research Institute, 33 (3), 419-424
  7. Dawson, L. & Boopaty, R. (2008) Cellulosic ethanol production from sugarcane bagasse without enzymatic saccharification. Bioresources 3, 452-460
  8. Hailu, S., Demel, T., Sileshi, N. & Fassil, A. (2004) Some biological characteristics that foster the invasion of P. juliflora (Sw.) DC.At Middle Awash Rift Valley, North-eastern Ethiopia. Journal of Arid Environment 58, 34-153
  9. Hoi, W. (2003) Potential of biomass utilization for energy in Asia Pacific experience of the Philippine situation, Forest Research Institute. Kepong, Kuala Lumpur Malaysia
  10. Joshi, B., Raj Bhatt, M., Sharma, D., Joshi, J., Malla, R. & Sreerama, L. (2011) Lignocellulosic ethanol production: Current practices and recent developments. Biotechnology and Molecular Biology Review, 6(8), 172-182
  11. Haile, M. (2014) Integrated volarization of spent coffee grounds to biofuels. Biofuel Research Journal 2, 65-69
  12. Haile, M., Araya, A., & Nigist, A. (2013) Investigation of Waste Coffee Ground as a Potential Raw Material for Biodiesel Production. International journal of renewable energy research, 3 (4)
  13. Manikandan K, Saravanan S. Kinetics studies on bio-ethanol production from banana peel waste using mutant strain of Saccharomyces cervisiae. Indian J Biotechnol. 2008;7:83–88
  14. Ministry of Mines and Energy (2011) Energy Policy of Ethiopia, Japan International Cooperation Agency (JICA) Tokyo international center
  15. Nutawan, Y., Phattayawadee, P., Pattranit, T. & Mohammad, N. (2010) Bioethanol Production from Rice Straw. Energy Research J. 1, 26-31
  16. Onuki, S. (2005) Bioethanol, Industrial production process, and recent studies; USA organic and food wastes. Journal of Practices and Technologies, 13, 1-11
  17. Pasiecznik, N.M., Felker, P., Harris, P.J., Harsh, L.W., Cruz, G., Tewari, J.C., Cadoret, K. & Maldonado, L.J. (2001) The Prosopis juliflora – Prosopis pallida Complex: a monograph. HDRA, Coventry, UK.pp 162
  18. Pikūnas, A., Pukalskas, S. & Grabys, J. (2003) Influence of composition of gasoline-ethanol blends on parameters of internal combustion engines. Journal of kones internal combustion Engines, 10, 3-4
  19. Prasad, M.P., Rekha, S., Tamilarasan, M. & Subha, K.S. (2009). Production Of Bioethanol Using Various Agricultural Raw Materials By Two Step Enzymatic Process. Advanced Biotech, 41 – 43
  20. Raghavendra B, Havannavar Geeta SG. Pre-treatment of agroresidues for release of maximum reducing sugar. Karnataka J Agric Sci. 2007;20:771–772
  21. Ryan, F. (2011) US Forest Service Technical Assistance, Trip to Ethiopia: Invasive species management. Report Submitted to USAID
  22. Shiferaw, H., Teketay, D., Nemomissa, S. and Assefa, F. (2004). Some biological characteristics that foster the invasion of Prosopis juliflora (Sw.) DC. at Middle Awash Rift Valley Area, northeastern Ethiopia. Journal of Arid Environments, 58: 134–153
  23. Steele, P., Breithaupt, J., & Labrada, R. (2009) Increased food security: control and management of Prosopis. Proceedings of an Expert Consultation, 4, Awash (Ethiopia), FAO
  24. Thuesombat, P., Thanonkeo, P., Laopaiboon, L., Laopaiboon, P., Yunchalard, S., Kaewkannetra, L. & Thanonkeo, S. (2007) The batch ethanol fermentation of Jerusalem artichoke using saccharomyces cerevisiae. Journal of sciences and Technology 7:93-96
  25. Weil, J., Dien, B., Bothast, R., Hendrickson, R., Mosier, N. & Ladisch, M. (2002) Removal of fermentation inhibitors formed during pretreatment of biomass by polymeric adsorbents. Ind. Eng. Chem. Res. 41, 6132–6138
  26. Woldesenbet AG, Shiferaw G, Chandravanshi BS. Bio-ethanol production from poultry manure at Bonga Poultry Farm in Ethiopia. Afr J Environ Sci Technol. 2013;7:435–440
  27. Woldesenbet AG, Woldeyes B, Chandravanshi BS. Bio-bio-ethanol production from wet coffee processing waste in Ethiopia. Springerplus. 2016; 5(1): 1903
  28. Zuzarte, F. (2007) Ethanol for Cooking - Feasibility of Small-scale Ethanol Supply and its Demand as a Cooking Fuel: Tanzania Case Study. KTH School of Energy and Environmental Technology, Heat and Power Technology, Stockholm, Sweden

Last update:

  1. Tuning the surface functionalities, textural properties and capacitance properties of reduced graphene oxide by utilizing environmentally threatening invasive weed as a reducing agent

    P. Bharathidasan, Thiruvenkatam Subramaniam, N.M. Sunju, S.R. Sivakkumar, S. Devaraj. Journal of Energy Storage, 42 , 2021. doi: 10.1016/j.est.2021.103149

  2. Prosopis Juliflora

    Pratiksha Patnaik, Tabassum-Abbasi, S.A. Abbasi. 2024. doi: 10.1016/B978-0-12-819824-7.00006-3

  3. The comprehensive characterization of Prosopis juliflora pods as a potential bioenergy feedstock

    G. Gayathri, Kiran Babu Uppuluri. Scientific Reports, 12 (1), 2022. doi: 10.1038/s41598-022-22482-9

  4. Mapping of Prosopis juliflora rate of expansion and developing species-specific allometric equations to estimate its aboveground biomass in the dry land of Ethiopia

    Dessie Assefa, Asnake Mekuriaw, Mathias Tesfaye, Habtamu Sewnet, Beyene Belay. Modeling Earth Systems and Environment, 9 (1), 2023. doi: 10.1007/s40808-022-01495-3

  5. Arid/semi-arid flora as a treasure trove of bioactives and bioenergy: the case for underutilized desert legumes towards environmental sustainability

    Tripti Joshi, Sumit Kumar Mandal, Vidushi Asati, Perinkulam Ravi Deepa, Pankaj Kumar Sharma. Environmental Science and Pollution Research, 31 (27), 2023. doi: 10.1007/s11356-023-29274-2

Last update: 2024-11-24 23:26:59

No citation recorded.