DOI: https://doi.org/10.14710/ijred.2022.45107

Extracted Pomace Olive Oil Use for the Preparation of Starch Graft Copolymer

Higher Institute for Applied Sciences and Technology, P. O. Box 31983 Damascus, Syrian Arab Republic

Received: 15 Sep 2021; Revised: 6 Jan 2022; Accepted: 20 Mar 2022; Available online: 10 Apr 2022; Published: 5 May 2022.
Editor(s): H. Hadiyanto
Open Access Copyright (c) 2022 The Authors. Published by Centre of Biomass and Renewable Energy (CBIORE)
Creative Commons License This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

Citation Format:
Abstract

In this work, the relevant parameters of a pomace olive oil consecutive solvent extraction method using ethanol, and petroleum ether are investigated from dry and wet pomace samples. It is found that, oil extraction from dry samples with petroleum ether showed a high yield (11.72±0.30%) with solvent recovery of 89%, while extraction yield with ethanol is (11.1±0.60%) with solvent recovery of 90%. Moreover, it is found that the oil extraction from wet samples with ethanol is possible but the economic feasibility is not proven as the solvent recovery is of 62%. On the other hand, the possibility of hydrolysis of the crude extracted pomace oil in alkaline medium is demonstrated in this work. In this context, the starch grafting of the obtained long chain mono-fatty acids was accomplished in the presence of Fenton's reagent in a Dimethyl formamide (DMFA)/Water solution. Sonication is used for reaction mixture homogeny and the biopolymer was obtained using domestic microwave heating. After characterizing the obtained grafting polymer, it was employed to prepare a composite material with polyvinyl alcohol. The prepared PVA composite film of grafted starch (PVA/gSt) has tensile strength of (5.84 MPa) while its elongation modulus increased by 123.6%. Moreover, it was observed, in this work, that (PVA/gSt) copolymerization increases both the crystalline structure and the morphological order. This result is contrary to the available literature related to copolymerization of starch with different mono acids. It is found that, the consecutive solvent extraction method is of promising aspect from technical and economic point of view and the grafted starch compatibility with other polymers may be improved. The PVA/gSt films could be applied as packaging films.

Fulltext View|Download
Keywords: Pomace olive oil; Solvent consecutive extraction; Mono-Fatty acids; Oleic acid; Starch graft copolymer,; Blend films.

Article Metrics:

Article Info
Section: Original Research Article
Language : EN
Recent articles
Impact of Photovoltaic Panel Orientation and Elevation Operating Temperature on Solar Photovoltaic System Performance Supply and Demand Characteristics of Palm Kernel Shell as a Renewable Energy Source for Industries Catalytic Co-Pyrolysis of Palm Oil Empty Fruit Bunch and Coal into Liquid Oil Enhanced Geothermal Systems – Promises and Challenges Mathematical Model of the Thermal Performance of Double-Pass Solar Collector for Solar Energy Application in Sierra Leone Bioconversion of Industrial Cassava Solid Waste (Onggok) to Bioethanol Using a Saccharification and Fermentation process More recent articles
Most cited articles
Enhancement of Energy Efficiency and Food Product Quality Using Adsorption Dryer with Zeolite Mathematical Modelling of Solar Photovoltaic Cell/Panel/Array based on the Physical Parameters from the Manufacturer’s Datasheet Optimization and Molecular Characterization of Syngas Fermenting Anaerobic Mixed Microbial Consortium TERI SA1 Cost optimization for the 100% renewable electricity scenario for the Java-Bali grid Design, Analysis and Optimization of a Solar Dish/Stirling System More cited articles
  1. Aburto, J., Alric, I., Borredon, E. (2005) Organic Solvent-free Transesterification of Various Starches with Lauric Acid Methyl Ester and Triacyl Glycerides. STARCH - STARKE, 57, 145–152. https://doi.org/10.1002/star.200400380
  2. Ačkar, Đ., Babić, J., Jozinović, A., Miličević, B., Jokić, S., Miličević, R., Šubarić, D. (2015) Starch modification by organic acids and their derivatives: a review. Molecules. 20(10), 19554–19570. https://doi.org/10.3390/molecules201019554
  3. Akay, F., Kazan, A., Celiktas, M.S., & Yesil-Celiktas, O. (2015) A holistic engineering approach for utilization of olive pomace. J. Supercrit. Fluids. 99, 1–7 . https://doi.org/10.1016/j.supflu.2015.01.025
  4. Caicedo, C., Aguirre Loredo, R. Y., Fonseca García, A., Ossa, O. H., Vázquez Arce, A., Calambás Pulgarin, H. L., & Ávila Torres, Y. (2019) Rheological, thermal, superficial, and morphological properties of thermoplastic achira starch modified with lactic acid and oleic acid. Molecules, 24(24), 4433. https://doi.org/10.3390/molecules24244433
  5. Castillo, L. A., López, O. V., García, M. A., Barbosa, S. E., Villar, M. A. (2019) Crystalline morphology of thermoplastic starch/talc nanocomposites induced by thermal processing. Heliyon, 5(6), 1-8. https://doi.org/10.1016/j.heliyon.2019.e01877
  6. Chanioti, Sofia; Tzia, Constantina (2018). Processing Parameters on the Extraction of Olive Pomace Oil and Its Bioactive Compounds: A Kinetic and Thermodynamic Study. Journal of the American Oil Chemists' Society, 95(3), 371–382. doi: 10.1002/aocs.12021
  7. Chanioti S, Katsouli M, Tzia C. (2021). Novel Processes for the Extraction of Phenolic Compounds from Olive Pomace and Their Protection by Encapsulation. Molecules. Mar 22;26(6):1781. doi: 10.3390/molecules26061781.PMID:33810031;PMCID:PMC8005142
  8. De Bruno, Alessandra; Romeo, Rosa; Fedele, Francesca L.; Sicari, Andrea; Piscopo, Amalia; Poiana, Marco (2018). Antioxidant activity shown by olive pomace extracts. Journal of Environmental Science and Health, Part B, (), 1–8. doi: 10.1080/03601234.2018.1462928
  9. de Moraes Crizel, Tainara; Haas Costa, Tania Maria; de Oliveira Rios, Alessandro; Hickmann Flôres, Simone (2016). Valorization of food-grade industrial waste in the obtaining active biodegradable films for packaging. Industrial Crops and Products, 87(), 218–228. doi: 10.1016/j.indcrop.2016.04.039
  10. de Moraes Crizel, Tainara; de Oliveira Rios, Alessandro; Alves, Vítor D.; Bandarra, Narcisa; Moldão-Martins, Margarida; Flôres, Simone Hickmann (2017). Active food packaging prepared with chitosan and olive pomace. Food Hydrocolloids, (), S0268005X17309840. doi: 10.1016/j.foodhyd.2017.08.007
  11. Difonzo, Graziana; Troilo, Marica; Squeo, Giacomo; Pasqualone, Antonella; Caponio, Francesco (2020). Functional Compounds From Olive Pomace to Obtain High-Added Value Foods - A Review. Journal of the Science of Food and Agriculture, (), jsfa.10478–. doi: 10.1002/jsfa.10478
  12. Egharevba, H.O. (2020) Chemical properties of starch and its application in the food industry. Chemical Properties of Starch, Martins Emeje, IntechOpen. 1-26. https://doi.org/10.5772/INTECHOPEN.87777
  13. Elsa Uribe, Roberto Lemus-Mondaca, Alexis Pasten, Sebastian Astudillo, Antonio Vega-Gálvez, Luis Puente-Díaz, and Karina Di Scala (2014). Dehydrated olive-waste cake as a source of high value-added bioproduct: Drying kinetics, physicochemical properties, and bioactive compounds. Chilean J. Agric. Res. vol.74 no.3 Chillán set. 2014. http://dx.doi.org/10.4067/S0718-58392014000300007
  14. Fang, J., Fowler, P., Tomkinson, J., Hill, C.A. (2002) An investigation ‎of the use of recovered vegetable oil for the preparation of starch ‎thermoplastics. Carbohydr. Polym. 50(4), 429–434. https://doi.org/10.1016/s0144-‎‎8617(02)00123-6.‎
  15. Gandhi, A. P., Joshi Krishna Jha, K. C., Parihar, V. S., Srivastav, D. C., Raghunadh, P., Kawalkar, J., Jain, S. K., & Tripathi, R. N. (2003) Studies on alternative solvents for the extraction of oil-I soybean. International Journal of Food Science and Technology, 38, 369–375. https://doi.org/10.1046/j.1365-2621.2003.00683.x
  16. Gao, J. , Luo, Z.-G., & Luo, F.-X. (2012) Ionic liquids as solvents for dissolution of cornstarch and homogeneous synthesis of fatty-acid starch esters without catalysts. Carbohydr. Polym. 89(4) 1215–1221. https://doi.org/10.1016/j.carbpol.2012.03.096
  17. Garg, S., Mittal, A., Premi, A. (2019) Synthesis and characterization of the ‎graft copolymers of starch for the application in packaging films. ‎ In: A. Agnihotri, K. Reddy, A. Bansal (eds) Sustainable Engineering. Lecture Notes in Civil Engineering, vol 30. Springer, Singapore. 63–73.‎ https://doi.org/10.1007/978-981-13-6717-5_7
  18. Gómez-Cruz, Irene; Cara, Cristóbal; Romero, Inmaculada; Castro, Eulogio; Gullón, Beatriz (2020). Valorisation of Exhausted Olive Pomace by an Eco-Friendly Solvent Extraction Process of Natural Antioxidants. Antioxidants, 9(10), 1010–. doi: 10.3390/antiox9101010
  19. Haroune, L. M., Zaidi, F., Medouni-adrar, S., & Kecha, M. (2018) Olive pomace: from an olive mill waste to a resource, an overview of the new treatments. Journal of Critical Reviews, 5(6) 1. https://doi.org/10.22159/jcr.2018v5i5.28840
  20. Kartika, I.A, Pontalier, P.Y., Rigal, L. (2010) Twin-screw extruder for oil processing of sunflower seeds: Thermo-mechanical pressing and solvent extraction in a single step. Industrial Crops and Products. 32(3), 297–304. https://doi.org/10.1016/j.indcrop.2010.05.005
  21. Kumar, S., Prasad, S.R., Banerjee, R., Agarwal, D.K., Kulkarni, K.S., & Ramesh, K.V. (2017) Green solvents and technologies for oil extraction from oilseeds. Chem. Cent. J. 11, 9. https://doi.org/10.1186/s13065-017-0238-8
  22. Lakhtar, H., Ismaili-Alaoui, M., Perraud-Gaime, I., Macarie, H., Roussos, S. (2009).Characterization of dried mixture of olive cake with olive mill wastewater: elemental, spectroscopie analyses (FTIR and 13C-NMR) and polyphénols dynamics. Olivebioteq, 657-663
  23. Lindeboom, N., Chang, P.R., Tyler, R.T. (2004) Analytical, biochemical and physicochemical aspects of starch granule size, with emphasis on small granule starches: A Review. Starke. 56(34), 89–99. https://doi.org/10.1002/star.200300218
  24. Lomege, J., LapinteNegrell, V., Robin, J.-J., & Caillol, S. (2018) Fatty acid-based radically polymerizable monomers: from novel polyacrylates to cutting-edge properties. Biomacromolecules. https://doi.org/10.1021/acs.biomac.8b01156
  25. Lu, Y., & Larock, R.C. (2009) Novel Polymeric Materials from Vegetable Oils and Vinyl Monomers: Preparation, Properties, and Applications. ChemSusChem. 2(2), 136–147. https://doi.org/10.1002/cssc.200800241
  26. Meziane, S. (2013) Optimization of oil extraction from olive pomace using response surface methodology. Food Science and Technology International, 19, 315–322. https://doi.org/10.1177/1082013212452476
  27. Meziane, S., Kadi, H., Daoud, K., Hannane, F. (2009) Application of experimental design method to the oil extraction from olive cake. J. Food Process. Preserv. 33(2), 176–185. https://doi.org/10.1111/j.1745-4549.2008.00240.x
  28. Miao, S., Wang, P., Su, Z., & Zhang, S. (2014) Vegetable-oil-based polymers as future polymeric biomaterials. Acta Biomater. 10(4), 1692–1704. https://doi.org/10.1016/j.actbio.2013.08.040
  29. Mittal, A., Garg, S., Kohli, D., Maiti, M., Jana, A.K., Bajpai, S. (2016) Effect of cross linking of PVA/starch and reinforcement of modified barley husk on the properties of composite films. Carbohydr. Polym. 151, 926–938. https://doi.org/10.1016/j.carbpol.2016.06.037
  30. Mittal, A., Garg, S., Premi, A., Giri, A. S. (2020) Synthesis of polyvinyl alcohol/modified starch-based biodegradable nanocomposite films reinforced with starch nanocrystals for packaging applications. Polymers and Polymer Composites, 1-12. https://doi.org/10.1177/0967391120922429
  31. Mustafa, P., Niazi, M. B. K., Jahan, Z., Rafiq, S., Ahmad, T., Sikander, U., Javaid, F. (2020) Improving functional properties of PVA/starch-based films as active and intelligent food packaging by incorporating propolis and anthocyanin. Polymers and Polymer Composites, 1-13. https://doi.org/10.1177/0967391120973503
  32. Pareta, R., & Edirisinghe, M. (2006) A novel method for the preparation of starch films and coatings. Carbohydrate Polymers 63(3), 425–431. https://doi.org/10.1016/j.carbpol.2005.09.018
  33. Paulo, Filipa; Santos, Lúcia (2020). Deriving valorization of phenolic compounds from olive oil by-products for food applications through microencapsulation approaches: a comprehensive review. Critical Reviews in Food Science and Nutrition, (), 1–26. doi: 10.1080/10408398.2020.1748563
  34. Pfister, D.P., Xia, Y., & Larock, R.C. (2011) Recent Advances in Vegetable Oil-Based Polyurethanes. ChemSusChem. 4(6), 703–717. https://doi.org/10.1002/cssc.201000378
  35. Simi, C.K., & Emilia Abraham, T. (2007) Hydrophobic grafted and cross-‎linked starch nanoparticles for drug delivery. Bioprocess Biosyst Eng. 30(3), 173–180.‎ https://doi.org/10.1007/s00449-007-0112-5
  36. Souilem, S., El-Abbassi, A., Kiai, H., Hafidi, A., Sayadi, S., & Galanakis, C. M. (2017) Olive oil production sector: environmental effects and sustainability challenges. Olive Mill Waste, 1–28. https://doi.org/10.1016/b978-0-12-805314-0.00001-7
  37. Tajau, R., Rohani, R., Alias, M.S., Mudri, N.H., Abdul Halim, K.A., Harun, M.H., Mat Isa, N., Che Ismail, R., Muhammad Faisal, S., Talib, M., Rawi Mohamed Zin, M., Izni Yusoff, I., Khairul Zaman, N., & Asyila Ilias, I. (2021) Emergence of Polymeric Material Utilising Sustainable Radiation Curable Palm Oil-Based Products for Advanced Technology Applications. Polymers. 13, 1865. https://doi.org/10.3390/polym13111865
  38. Thomas, A. (2000) Fats and Fatty Oils. Ullmann’s Encyclopedia of Industrial Chemistry. 1-73. https://doi.org/10.1002/14356007.a10_173
  39. Tomasik, P., & Schilling, C.H. (2004) Chemical modification of starch. Advances in Carbohydrate Chemistry and Biochemistry, Volume 59, 175–403. https://doi.org/10.1016/s0065-2318(04)59005-4
  40. Zarski, A., Ptak, S., Siemion, P., Kapusniak, J. (2016) Esterification of potato starch by a biocatalysed reaction in an ionic liquid. Carbohydrate Polymers, 137, 657–663. https://doi.org/10.1016/j.carbpol.2015.11.029
  41. Zhu, Y., Romain, C., & Williams, C.K. (2016) Sustainable polymers from renewable resources. Nature. 540(7633), 354–362. https://doi.org/10.1038/nature21001

Last update:

No citation recorded.

Last update: 2024-04-25 17:25:55

No citation recorded.