DOI: https://doi.org/10.14710/presipitasi.v20i1.153-164

Wastewater Treatment Plant Design for Batik Wastewater with Off-Site System Method in Ulu Gedong Sub-District, Jambi City

*Solikhati Indah Purwaningrum  -  Universitas Jambi, Indonesia
Huwan Syarifuddin  -  Universitas Jambi, Indonesia
Addion Nizori  -  Universitas Jambi, Indonesia
Yudha Gusti Wibowo orcid scopus publons  -  Institut Teknologi Sumatera, Indonesia

Citation Format:
Abstract

Batik is a cultural heritage of Indonesia in the form of textile crafts. The batik industry uses a lot of dyes that cause environmental pollution. The study results showed that Artisanal Small Scale Industry batik has yet to perform batik wastewater management to a technical standard. Design planning for batik wastewater management considers the conditions of wastewater discharge, dyes, characteristics of wastewater, the location to be served, and the location of Waste Water Treatment Plant. The design of the batik Waste Water Treatment Plant building is an equalization unit with dimensions of 4.6 m long, 2.3 m wide, and 4 m high, an anaerobic unit with dimensions of 10.5 m long, 4 m wide and 3.5 m high, a filtration unit with a diameter of 8 inches, 40 inches tall, control tub with dimensions of length 8 m, width 4 m, and height 3.5 m, and sludge drying bed with dimensions of length 15 m, width 15 m and height 1 m. The processing unit obtained water pollutant concentrations in the processed wastewater of 2.426 mg/L BOD, 0.543 mg/L of COD, and 0.0115 mg/L of TSS. This concentration shows that the WWTP design optimally reduce the pollutants in batik wastewater.

Fulltext View|Download
Keywords: Batik wastewater; WWTP; off-site system

Article Metrics:

Article Info
Section: Regional Case Study
Language : EN
Recent articles
Biofuel Successful Strategies towards Sustainable Development: A Bibliometrics Analysis Application of Free Water Surface Constructed Wetland for Reduction of Brantas River Pollutants Compost Quality of Compost Process Grass Waste with Composting Bin Method The Potential of Landfill Waste in Rembang City as Raw Material for Refuse Derived Fuel (RDF) Analysis of Weight, Composition, Density, and Recycling Potential of Floating Marine Debris in Pasie Nan Tigo Area, Padang City Risk Factor Analysis of Dust Exposure with Symptoms of Respiratory Disorder in Brick Industry Workers in Tegowanuh Sub-District, Kaloran District, Temanggung Regency Analysis of Water Quality Status in Tuntang River, Semarang Regency in 2022 More recent articles
Most cited articles
EVALUASI KINERJA INSTALASI PENGOLAHAN AIR MINUM (IPAM) KARANGPILANG I PDAM SURYA SEMBADA KOTA SURABAYA SECARA KUANTITATIF KAJIAN PUSTAKA POTENSI PEMANFAATAN GREYWATERSEBAGAI AIR SIRAM WC DAN AIR SIRAM TANAMAN DI RUMAH TANGGA Potensi Chlorella Sp. untuk Menyisihkan COD dan Nitrat dalam Limbah Cair Tahu KOMBINASI FEEDING BIOSTARTER DAN AIR DALAM ANAEROBIK DIGESTER ANALISIS PENGARUH HIDROLIKA SUNGAI TERHADAP TRANSPORT BOD DAN DO DENGAN MENGGUNAKAN SOFTWARE QUAL2E (STUDI KASUS DI SUNGAI KALIGARANG, SEMARANG ) More cited articles
  1. Aliyaddin & Wesen. 2018. Batik industrial wastewater treatment using bioball-mediumed hybrid bioreactors. Scientific Journal of Environmental Engineering, 8(2) 78-87
  2. Arikunto. 2010. Research procedure of a practical approach. Rineka Cipta; Jakarta
  3. Busyairi, A., Kahar, N., Sariyadi. 2020. Effectiveness of domestic grey water wastewater treatment with anaerobic biofilter process and aerobic biofilter (case study: ipal inbis permata bunda, bontang). Engineering Porch, 5(4) 1306-1312
  4. Central Statistics Agency of Jambi City. 2015. Jambi city in figures 2015. Central Statistics Agency: Jambi City
  5. Indonesian National Standardization Agency. 2011. Sludge drying bed planning procedures at drinking water treatment plants with sludge drying beds. SNI 7510: 2011. Jakarta: BSN
  6. Dehghani, M. & Alizadeh, M. H., 2016. the effects of the natural coagulant moringa oliefera and alum in wastewater treatment at the banda abbas oil refinery. Environmental Health Engineering and Management Journal, 3(4) 225-230
  7. Desiana, Y. & Sujarwata. 2017. Cellulose corn husk as cromium (cr) metal adsorbent in batik liquid waste. Unnes Physics Journal, 6(1) 19-24
  8. Dewi, J. & Nurmiyanto. 2018. Reduction of BOD, COD, TSS, and color levels of giriloyo batik village industrial waste using anaerobic-aerobic combination reactors. Thesis. Environmental Engineering Study Program, Faculty of Civil Engineering and Planning, Universitas Islam Indonesia; Yogyakarta
  9. Egbuikwem & Sangodoyin. 2013. Coagulation efficacy of moringa oleifera seed exract compared toalum for removal of turbidity and e.coli in three diffferent water sources. European International Journal of Science and Technology, 2(7) 13-19
  10. Eskani & Sulaeman. 2016. Effectiveness of batik wastewater treatment by chemical and biological means. Garuda Journal, 22 16-27
  11. Firmansyah & Razif. 2016. Comparison of anaerobic biofilter wwtp design with rotating biological contractor for textile liquid waste in surabaya. Its Engineering Journal, 5(2) 166-171
  12. Formentini-Dchmitt, D.A., Teresinha, V., Bergamasco, S.V., & Fagundes-Klen. 2013. Ultrafiltration combined with coagulation/flocculation/sedimentation using moringa oliefera as coagulant to treat dairy industry wastewater. Springer Science + Business Media, 224(1682) 1-10
  13. Hastutiningrum, S., & Purnawan. 2017. Pre-design of batik industry wastewater treatment plant (wwtp) (case study of batik sembung, sembungan rt.31/rw.14, gulurejo, lendah, kulonprogo). Excergical Journal, 14(2) 52-62
  14. Kaswinarni. 2007. Technical study of solid and liquid waste treatment industry tofu industrial study tofu away semarang, simple kendal and crow sipat boyolali. Thesis. Environmental Science Study Program, Postgraduate Program, Diponegoro University: Semarang
  15. kiswanto, R. & Wintah. 2019. Batik liquid waste treatment using nanofiltration membrane technology in pekalongan city. Pekalongan R&D Journal, 17 72-82
  16. Kurniawan, M.W., Purwanto, P., and Sudarso, S. 2013. Sustainable batik msme center wastewater management strategy in sukoharjo regency. Journal of Environmental Sciences, 11(2) 62-72
  17. Madrona, S., Tonon, R., Paraiso & Bergamasco. 2017. Use of moringa oliefera in combined coagulaltion-filtration process for water treatment. The Italian Association of Chemical Engineering, 57, 1195-1200
  18. Metcalf and Eddy. 2003. Wastewater engineering treatment and reuse. New York, America: MC. Graw-Hill
  19. Muljadi. 2009. Efficiency of liquid waste treatment plant batik printing industry with physico-chemical and biological methods against decreasing pollutant parameters (bod, cod, and chrome heavy metals (cr) (case study in butulan village makam haji sukoharjo). Equilibrium, 8(1) 7-16
  20. Pratiwi, R.S. 2015. Domestic wastewater management planning in keputih village, surabaya. Thesis, Department of Environmental Engineering, Sepuluh Nopember Institute of Technology. Digital Library
  21. Regulation of the State Minister of the Environment Number 05 of 2014 concerning Wastewater Quality Standards
  22. Said, N.I. 2001. Hospital wastewater treatment with biological processes of inherent cultures using wasp nest plastic media. Journal of Environmental Technology, 2(3) 223-240
  23. Said Ni. 2009. Testing the work of ready-to-drink water treatment with biofilter, ultrafiltration and reverse osmosis (ro) processes with raw water of river water. Journal of Environmental Technology, 5(2) 145-161
  24. Said, N.I. 2017. Wastewater treatment technology. Jakarta : Erlangga
  25. Sitanggang, P. Y. 2017. Textile and batik waste treatment in indonesia. Journal of Environmental Engineering, 1(12) 1–10
  26. Setianingsih. 2019. Batik industry wastewater management with granule aerobic system as one of the efforts in supporting environmentally friendly industries. Thesis. Master of Environmental Science Study Program, Faculty of Graduate School, Diponegoro University; Semarang
  27. Susilawati, A. & Nasip. 2016. Utilization of used syringes as biofilter media in determining cod & bod levels of laundry wastewater. Journal of Health Vocational, 11(2) 119-125
  28. Wahyuningsih, G., Hanafi, A., dan Cahyadi, A. 2016. The effect of competence on the performance of jambi batik micro, small business entrepreneurs (mses) in the opposite area of jambi city. BRIDGE-Journal of Business and Applied Management Sciences, 13(1) 41–54
  29. Zee, F.P. 2002. Anaerobic azo dye reduction. doctoral thesis, wageningen university. Wageningen, The Netherlands, 142 pages

Last update:

No citation recorded.

Last update: 2024-12-25 21:28:00

No citation recorded.