DOI: https://doi.org/10.14710/ijred.3.3.228-235

Combustion characteristics of diesel engine using producer gas and blends of Jatropha methyl ester with diesel in mixed fuel mode

1Agricultural and Food Engineering Department , Indian Institute of Technology, Kharagpur, India

2Indiara Gandhi Agricultural University, Raipur, India, India

Published: 15 Oct 2014.
Editor(s):

Citation Format:
Abstract

An experimental investigation was performed to study the combustion characteristics of diesel engine fuelled with producer gas-biodiesel in dual fuel mode. Three different fuel blends of Jatropha methyl ester with high speed diesel (HSD) (B10, B20) and B100 were used with producer gas obtained from the gasification of briquettes made from de-oiled Jatropha seed cake. The increments in load on the engine increased the brake thermal efficiency, exhaust gas temperature and lowered the brake specific energy consumption. The ignition delays in dual-fuel mode of operation for both the fuels were longer than for single-fuel mode of operation. Combustion pressure and heat release rate (HRR) patterns at different engine loads were found to be similar for biodiesel and HSD. In dual-fuel mode, the peak pressure and HRR for producer gas–biodiesel dual-fuel were slightly lower than those of producer gas–diesel combustion at full load condition. Significantly lower NOx emissions were obtained under the dual fuel mode of operation for both pilot fuels compared to the single-fuel mode especially HSD under all test conditions.

Fulltext View|Download
Keywords: Biodiesel, Combustion characteristics; Dual fuel mode; Ignition delay; Producer gas

Article Metrics:

Article Info
Section: Original Research Article
Language : EN
Recent articles
Incorporating Root Crops under Agro-Forestry as the Newly Potential Source of Food, Feed and Renewable Energy Analysing the potential of retrofitting ultra-low heat loss triple vacuum glazed windows to an existing UK solid wall dwelling Thermal effects investigation on electrical properties of silicon solar cells treated by laser irradiation More recent articles
Most cited articles
Optimum Tilt Angle at Tropical Region Batch and Fed-Batch Fermentation System on Ethanol Production from Whey using Kluyveromyces marxianus Soybean Opportunity as Source of New Energy in Indonesia Bioelectricity Generation From Single-Chamber Microbial Fuel Cells With Various Local Soil Media and Green Bean Sprouts as Nutrient Modeling Operation Problem of Micro-grids Considering Economical, Technical and Environmental issues as Mixed-Integer Non-Linear Programming More cited articles
  1. Alfuso, S., Auriemma, M., Police, G. & Prati, M.V. (1993) The effect of methyl ester of rapeseed oil on combustion and emissions of DI engines. SAE – 932801
  2. Raheman, H. & Phadatare, A.G. (2004) Diesel engine emissions and performance from blends of karanja methyl ester and diesel. Biomass and Bioenergy, 27 (4): 393-397
  3. Usta, N. (2005) An experimental study on performance and exhaust emissions of a diesel engine fuelled with tobacco seed oil methyl ester. Energy Conversion and Management, 46: 2373–2386
  4. Deshmukh, S.J. & Bhuyar L.B. (2009) Transesterified Hingan (Balanites) oil as a fuel for compression ignition engine. Biomass and Bioenergy, 33: 108–112
  5. Buyukkay, E. (2010) Effects of biodiesel on a DI diesel engine performance, emission and combustion characteristics. Fuel, 89: 3099–3105
  6. Banapurmath, N.R., Tewari, P.G. & Hosmath, R.S. (2008) Experimental investigations of a four-stroke single cylinder direct injection diesel engine operated on dual fuel mode with producer gas as inducted fuel and Honge oil and its methyl ester (HOME) as injected fuels. Renewable Energy, 33: 2007-2018
  7. Mustafi, N.N. & Raine, R.R. (2008) A study of the emissions of a dual fuel engine operating with alternative gaseous fuels. SAE 01-1394 (2008)
  8. Maji, S., Pal, A. & Aror, B.B. (2008) Use of CNG and diesel in CI engines in dual fuel mode. SAE 28-0072
  9. Jie, S., Jun, Q. & Mingfa, Y. (2003). Turbocharged diesel/CNG dual-fuel engines with intercooler: combustion, emissions and performance. SAE 01-3082
  10. Yoon, S.H. & Lee, C.S. (2011) Experimental investigation on the combustion and exhaust emission characteristics of biogas–biodiesel dual-fuel combustion in a CI engine. Fuel Processing Technology, 92: 992–1000
  11. Heywood, J.B. (1988) Internal Combustion Engine Fundamentals, McGraw-Hill Book Co
  12. Senthil, K.M., Kerihuel, A., Bellettre, J. & Tazerout, M. (2005) Experimental investigations on the use of preheated animal fat as fuel in a compression ignition engine. Renewable Energy, 30: 2314–2323
  13. Canakci, M., Ozsezen, A.N. & Turkcan, A. (2009) Combustion analysis of preheated crude sunflower oil in an IDI diesel engine. Biomass and Bioenergy, 33 (5): 760–767
  14. Devan, P.K. & Mahalakshmi, N.V. (2009) Study of the performance, emission and combustion characteristics of a diesel engine using poon oil-based fuels. Fuel Processing Technology, 90 (4): 513–519
  15. Noureddini, H. & Zhu, D. (1997) Kinetics of transesterification of soybean oil. J Am Oil Chem Soc, 74: 1457–1463
  16. Karim, G.A. (1983) The dual fuel engine of the compression ignition type—prospects, problems and solutions—a review, SAE – 831073
  17. Phan, M.D. & Kanit, W. (2007) Study on biogas premixed charge diesel dual fuelled engine. Energy Conversion and Management, 48: 2286–2308

Last update:

  1. Experimental Investigations on Dual-Fuel Engine Fueled with Tertiary Renewable Fuel Combinations of Biodiesel and Producer—Hydrogen Gas Using Response Surface Methodology

    Sushrut S. Halewadimath, Nagaraj R. Banapurmath, V. S. Yaliwal, V. N. Gaitonde, T. M. Yunus Khan, Chandramouli Vadlamudi, Sanjay Krishnappa, Ashok M. Sajjan. Sustainability, 15 (5), 2023. doi: 10.3390/su15054483

  2. Investigations on the performance, emission and combustion characteristics of a dual-fuel diesel engine fueled with induced bamboo leaf gaseous fuel and injected mixed biodiesel-diesel blends

    Van Nhanh Nguyen, Biswajeet Nayak, Thingujam Jackson Singh, Swarup Kumar Nayak, Dao Nam Cao, Huu Cuong Le, Xuan Phuong Nguyen. International Journal of Hydrogen Energy, 54 , 2024. doi: 10.1016/j.ijhydene.2023.06.074

  3. Clean gaseous fuel application in diesel engine: A sustainable option for rural electrification in India

    S. Das, D. Kashyap, P. Kalita, V. Kulkarni, Y. Itaya. Renewable and Sustainable Energy Reviews, 117 , 2020. doi: 10.1016/j.rser.2019.109485

  4. Performance and emission characteristics of CIE using hydrogen, biodiesel, and massive EGR

    Miqdam Tariq Chaichan. International Journal of Hydrogen Energy, 43 (10), 2018. doi: 10.1016/j.ijhydene.2017.09.072

  5. Nanotechnology-based biodiesel: A comprehensive review on production, and utilization in diesel engine as a substitute of diesel fuel

    Thanh Tuan Le, Minh Ho Tran, Quang Chien Nguyen, Huu Cuong Le, Van Quy Nguyen, Dao Nam Cao, Prabhu Paramasivam. International Journal of Renewable Energy Development, 13 (3), 2024. doi: 10.61435/ijred.2024.60126

  6. Use of hydrogen in dual-fuel diesel engines

    Seyyed Hassan Hosseini, Athanasios Tsolakis, Avinash Alagumalai, Omid Mahian, Su Shiung Lam, Junting Pan, Wanxi Peng, Meisam Tabatabaei, Mortaza Aghbashlo. Progress in Energy and Combustion Science, 98 , 2023. doi: 10.1016/j.pecs.2023.101100

Last update: 2024-12-25 21:01:27

  1. Design and fabrication of a downdraft gasifier coupled with a small-scale diesel engine

    Rith M.. Engineering and Applied Science Research, 47 (1), 2020.

  2. Experimental analysis of a dual-fuel engine fueled by producer gas derived from pine leaves and cattle dung briquettes

    Dabi M.. ASME 2015 Gas Turbine India Conference, GTINDIA 2015, 2015. doi: 10.1115/GTINDIA2015-1263

  3. The effect of jatropha seed cake producer gas flow rates on a diesel engine operated on dual fuel mode at high engine speed

    Rith M.. Engineering and Applied Science Research, 46 (4), 2019. doi: 10.14456/easr.2019.34

  4. Clean gaseous fuel application in diesel engine: A sustainable option for rural electrification in India

    S. Das, D. Kashyap, P. Kalita, V. Kulkarni, Y. Itaya. Renewable and Sustainable Energy Reviews, 117 , 2020. doi: 10.1016/j.rser.2019.109485

  5. Performance and emission characteristics of CIE using hydrogen, biodiesel, and massive EGR

    Miqdam Tariq Chaichan. International Journal of Hydrogen Energy, 43 (10), 2018. doi: 10.1016/j.ijhydene.2017.09.072

  6. The combustion and emission characteristics of the diesel engine operated on a dual producer gas-diesel fuel mode

    Rith M.. Engineering and Applied Science Research, 46 (4), 2019. doi: 10.14456/easr.2019.40

  7. Design and fabrication of a low-cost research facility for the study of combustion characteristics of a dual producer gas-diesel engine

    Rith M.. Engineering and Applied Science Research, 47 (4), 2020. doi: 10.14456/easr.2020.48

  8. Optimization of control factors for a diesel engine fueled with jatropha seed producer gas on dual fuel mode

    Rith M.. International Energy Journal, 19 (3), 2019.

  9. Optimization of diesel injection timing, producer gas flow rate, and engine load for a diesel engine operated on dual fuel mode at a high engine speed

    Rith M.. Engineering and Applied Science Research, 46 (3), 2019.