DOI: https://doi.org/10.14710/presipitasi.v21i1.70-79

Biogas Purification using Modified Red Mud Adsorbent with a Study of the Length of the Adsorbent Column

*Wivina Diah Ivontianti scopus  -  Universitas Tanjungpura, Indonesia
Gayu Ika Putri  -  Universitas Tanjungpura, Indonesia
Rinjani Ratih Rakasiwi  -  Universitas Tanjungpura, Indonesia
Syahrul Khairi  -  Universitas Tanjungpura, Indonesia
Sri Rezeki  -  Universitas Tanjungpura, Indonesia
Aini Sulastri  -  Universitas Tanjungpura, Indonesia

Citation Format:
Abstract

This study used red mud as an adsorbent for biogas purification. However, red mud had to undergo dealumination and calcination processes before being used as an adsorbent. Several acids, including 1 M HCl and 1M H2SO4, were employed in the red mud dealumination process, which was then analysed by XRF and GSA instruments. The results show that the best type of acid for the dealumination process was HCl with a Si/Al ratio, total pore volume, surface area and pore radius of 1.697; 67,081 m2/g; 0.1624 cm3/g; 48.4242 Å. The biogas purification process was carried out using red mud adsorbent dealuminated with HCl by varying the length of the adsorbent column, such as 10, 20 and 30 cm, and the contact time of 5, 10, 15 and 20 min. The optimum column length variation was 30 cm. The results obtained for this variation were a decrease in CO2 content of 292742.30 ppm with an efficiency of 19.08%. The increase in CH4 was 378232.69 ppm with a percentage increase of 240.28%.

Fulltext View|Download
Keywords: Adsorbent; biogas; dealumination; purification; red mud

Article Metrics:

Article Info
Section: Original Research Article
Language : EN
Recent articles
The Review Study of Environmental Education Curriculum in Climate Change Mitigation The Effectiveness of Using Eco-Friendly Bag to Support Sustainable Development Goals: A Review Incorporating Inhibition Effects and Hydrolysis Biokinetics into the Mathematical Model of Anaerobic Fermentation Biochar-Based Subsurface-Flow Wetland from Crumb Rubber Scrap in Treatment of Landfill Leachate Risk Factors of Unsafe Behavior among Construction Workers Utilization of Sludge from Cow Dung Biogas as Additional Feed for Sangkuriang Catfish (Claries gariepinus) Identifying Factors Influencing Sanitation Condition in Homes within Jatisari Urban Village, Semarang City Life Cycle Assessment to Compare the Environmental of Food Waste Management System in Semarang City Phytoplankton Diversity as Bioindicator of Water Quality in Mangrove Area of Surabaya East Coast More recent articles
Most cited articles
ELECTRICITY GENERATION FROM LANDFILL GAS Kajian Dampak Rencana Pembangunan Kawasan Wisata Marina di Pesisir Kabupaten Belitung terhadap Kualitas Lingkungan Sekitarnya EVALUATION ON COMMUNITY BASED FOREST MANAGEMENT IMPLEMENTATION IN RANDUBLATUNG, BLORA KAJIAN PUSTAKA POTENSI PEMANFAATAN GREYWATERSEBAGAI AIR SIRAM WC DAN AIR SIRAM TANAMAN DI RUMAH TANGGA PENENTUAN CAMPURAN LUMPUR LAPINDO SEBAGAI SUBSTITUSI PASIR DAN SEMEN DALAM PEMBUATAN PAVING BLOCK RAMAH LINGKUNGAN More cited articles
  1. Abdullah, S., Permana, D.A., Yuliandita, R., 2015. Pengaruh Komposisi Adsorben Campuran (Zeolit-Semen Putih) dan Waktu Adsorpsi Produk Gas Metana terhadap Kualitas Biogas sebagai Bahan Bakar Alternatif. Jurnal Teknik Kimia, 21(3), 1–6
  2. Adisasmito, S., Rasrendra,C.B., Alfadhli, M.Q., Al Ghifary, M.F., 2020. Hydrogen Sulfide Separation from Biogas Using Laterite Soil Adsorbent. Materials Science Forum, 988 MSF, 144–150
  3. Ahmed, S., Meng, T., Taha, M., 2020. Utilization of Red Mud for Producing A High Strength Binder by Composition Optimization and Nano Strengthening. Nanotechnology Reviews, 9(1), 396–409
  4. Athallah, A., Iskandar, N., 2022. Efek Penambahan Binder Bentonit Terhadap Kekuatan Katalis Zeolit Alam. Jurnal Teknik Mesin S-1, 10(1), 49–52
  5. Aulia, S., 2022. Red Mud Air Purifier (REPAF): Inovasi Teknologi Berbahan Baku Tailing Bauksit Sebagai Penyerap Asap Kebakaran Hutan di Riau. Journal of Embedded System Security and Intelligent System, 03(02), 85–93
  6. Dewi, D.S., Dewi, Z.Z., Maryono., 2019. Pengaruh Waktu Kontak dan pH Terhadap Ion Cr (VI) dalam Limbah Tekstil Menggunakan Bioadsorben Daun Jambu Biji dan Daun Teh. Jurnal Teknik: TEKNIKA, 5(2), 141–158
  7. Gantina, M.T., Farhani, D., 2020. Penurunan CO2 Biogas dengan Metoda Adsorpsi Menggunakan Zeolit Alam. Jurnal Energi, 10(1), 49–52
  8. Hien, L.P.T., Huy, L.T.A., Thanh, P.D., Thi, L.T.K., Le, B.K., Khoa, L.N.D., Vinh, D.Q., Vi, T.D., Hai, P.H., Thuy, V.T.T., Huy, N.N., 2019. Preparation of activated red mud and its application for removal of hydrogen sulfide in air. Science & Technology Development Journal - Engineering and Technology, 3(2)
  9. Iriani, P., Heryadi, A., 2014. Pemurnian Biogas Melalui Kolom Beradsorben Karbon Aktif. Sigma-Mu Politeknik Negeri Bandung, 6(2), 36–42
  10. Ismettulloh, M., Fajar, G.T., Nuryoto, K., 2019. Modifikasi Zeolit Alam Bayah Menggunakan Asam dan Pengaplikasiannya dalam Pengurangan Amonium pada Kolam Ikan Bandeng. Jurnal Integrasi Proses, 8(1), 7–13
  11. Liu, Y. Naidu, R., 2014. Hidden Values in Bauxite Residue (Red Mud): Recovery of Metals. Waste Management (34), 2662–2673
  12. Maleiva, L.T.N., Sitorus, B., Jati, D.R., 2015. Penurunan Konsentrasi Gas Karbon Monoksida dari Kendaraan Bermotor Menggunakan Adsorben Zeolit Alam. JKK, 4(1), 35–42
  13. Minh, V.X., 2017. Red Sludge Activation Study to Adsorb Some Polluted Anions in The Water Environment. Vietnam Academy of Sciences and Technology
  14. Mrosso, R., Machunda, R. Pogrebnaya, T., 2020. Removal of Hydrogen Sulfide from Biogas Using a Red Rock. Journal of Energy, 2020, 2309378
  15. Nurfitriyani, A., Wardhani, E., Dirgawati, M., 2013. Penentuan Efisiensi Penyisihan Kromium Heksavalen (Cr6+) dengan Adsorpsi Menggunakan Tempurung Kelapa secara Kontinyu. Reka Lingkungan, 2(1), 57–68
  16. Pertiwiningrum, A., 2016. Instalasi Biogas. Yogyakarta: CV. Kolom Cetak
  17. Prajapati, S.S., Najar, P.A.M., Tangde, V.M., 2016. Removal of Phosphate Using Red Mud: An Environmentally Hazardous Waste By-Product of Alumina Industry. Advances in Physical Chemistry
  18. Ritonga, A.M., Masruhi, M., Novita, D., 2021. Pemurnian Biogas Dengan Metode Adsorbsi pada Variasi Waktu Pemurnian dan Laju Aliran Menggunakan Adsorben Arang Aktif dan Siliki Gel. Journal of Agricultural and Biosystem Engineering Research, 2(2), 64
  19. Sen, T.K., 2018. Air, Gas, and Water Pollution Control Using Industrial And Agricultural Solid Wastes Adsorbent. New York: CRC Press
  20. Side, S., Putri, S.E., Pratiwi, D.E., Rahma, A., Rahman, A., 2023. The Effect of Acid Treatment on The Characteristics of Modernite Zeolite. XII(2), 114–123
  21. Simanjuntak, V., Wirawan, S.P.I., Arthawan, A.K.G., 2023. Pengaruh Jenis Adsorben dan Panjang Kolom terhadap Durasi Pemurnian Asap Cair Tempurung Kelapa. JURNAL BETA (Biosistem Dan Teknik Pertanian), 11(02), 245–253
  22. Sulistyowati, N., Darmawan, A., 2018. Jurnal Kimia Sains dan Aplikasi Effect of Acid on Natural Zeolite Dealumination on Indigo Carmine Adsorption Capability. 21(2), 102–106
  23. Sushil, S., Batra, V.S., 2012. Modification of Red Mud by Acid Treatment and Its Application for CO Removal. Journal of Hazardous Materials, 203–204, 264–273
  24. Tangde, V.M., Prajapati, S.S., Khaty, N.T., 2019. Activation and utilization of waste material of alumina industry: Red mud. Materials Today: Proceedings, 29(xxxx), 753–759
  25. Thanakunpaisit, N., Jantarachat, N., Onthong, U., 2017. Removal of Hydrogen Sulfide from Biogas using Laterite Materials as an Adsorbent. Energy Procedia, 138, 1134–1139
  26. Widhiyanuriyawan, D., Hamidi, N., Trimandoko, C., 2014. Purifikasi Biogas dengan Variasi Ukuran dan Massa Zeolit terhadap Kandungan CH4 dan CO2. Jurnal Rekayasa Mesin, 5(3), 27–32
  27. Widyastuti, A., Sitorus, B., Jayuska, A., 2013. Karbon Aktif dari Limbah Cangkang Sawit sebagai Adsorben Gas Dalam Biogas Hasil Fermentasi Anaerobik Sampah Organik. Jurnal Kimia Khatulistiwa 2(1), 30–33
  28. Yahya, Y., Tamrin, S., Triyono., 2018. Produksi Biogas dari Campuran Kotoran Ayam, Kotoran Sapi, dan Rumput Gajah Mini (Pennisetum Purpureum Cv. Mott) dengan Sistem Batch. Jurnal Teknik Pertanian Lampung (Journal of Agricultural Engineering), 6(3), 151–160
  29. Zulkefli, N.N., Masdar, M.S.W., Ishak, R.W., Jahim, J.E., Majlan, H.S., Rejab, A.M., Lye., C.C., 2017. Mathematical modelling and simulation on the adsorption of Hydrogen Sulfide (H2S) gas. IOP Conference Series: Materials Science and Engineering, (1) 206

Last update:

No citation recorded.

Last update: 2024-12-25 18:30:12

No citation recorded.