DOI: https://doi.org/10.14710/ijred.6.1.37-44

Kinetic and Enhancement of Biogas Production For The Purpose of Renewable Fuel Generation by Co-digestion of Cow Manure and Corn Straw in A Pilot Scale CSTR System

1Biosystem Engineering, University of Tabriz, Tabriz, Iran, Iran, Islamic Republic of

2Department of Biosystem Engineering, University of Tabriz, Tabriz, Iran, Iran, Islamic Republic of

Published: 22 Mar 2017.
Editor(s): H Hadiyanto
Open Access Copyright (c) 2017 International Journal of Renewable Energy Development

Citation Format:
Abstract

Biogas production from anaerobic co-digestion of cow manure (CM) and corn straw residue (CSR) were experimentally investigated using a completely stirred tank reactor (CSTR) under semi- continuously feeding circumstance at mesophilic (35°C±2) temperature. The pilot-scale digester with 180 L in volume was employed under experimental protocol to examine the effect of the change in organic loading rate on efficiency of biogas production and to report on its steady-state performance. An average organic loading rates of 2 and 3 kg VS. (m-3.d-1) and a hydraulic retention time (HRT) of 25 days was examined with respect to two different CM to CSR mixing ratios of 100:0 , 75:25 and 50:50, respectively. The results showed both organic loading rates at co-digestion of CM+ CSR gave better methane yields than single digestion of cow manure. The biogas production efficiency was obtained 0.242, 0.204, 0.311 0.296, 259.5 and 235 m3.(kg VS input)-1 for 2 and 3 kg VS.(m-3.d-1) at CM to CSR mixing ratios of100:0 , 75:25 and 50:50, respectively. The reactor showed stable performance with VS reduction between 55-74% during different runs. With increment of loading rate, the VS degradation and biogas yield decreased. Modified Gompertz and logistic plot equation was employed to model the methane production at different organic loading rates and substrate concentrations. The equations gave a good approximation of the maximum methane production (rm) and the methane yield potential (P) with correlation coefficient (R2) over 0.99.

Article History: Received Oct 25th 2016; Received in revised form Dec 19th 2016; Accepted 2nd January 2017; Available online

How to Cite This Article: Taghinazhad. J., Abdi, R. and Adl, M. (2017). Kinetic and Enhancement of Biogas Production for the purpose of renewable fuel generation by Co-digestion of Cow Manure and Corn Straw in a Pilot Scale CSTR System. Int Journal of Renewable Energy Development, 6(1),37-44

http://dx.doi.org/10.14710/ ijred.6.1.37-44

 

 

 
Fulltext View|Download
Keywords: Anaerobic co-digestion; cow manure; corn straw; modeling; semi-continuously

Article Metrics:

Article Info
Section: Original Research Article
Language : EN
Recent articles
Preliminary Investigation on Generation of Electricity Using Micro Wind Turbines Placed on A Car Performance Analysis of Maximum Power Point Tracking Algorithms Under Varying Irradiation Bioelectricity Production and Comparative Evaluation of Electrode Materials in Microbial Fuel Cells Using Indigenous Anode-Reducing Bacterial Community from Wastewater of Rice-Based Industries More recent articles
Most cited articles
Characterization and Performance Test of Palm Oil Based Bio-Fuel Produced Via Ni/Zeolite-Catalyzed Cracking Process Influence of the Rubber Seed Type and Altitude on Characteristic of Seed, Oil and Biodiesel VCO Production from Fresh Old Coconut Bunch by Circulating and Pumping Method Techno-Economic Evaluation of Solar Irrigation Plants Installed in Bangladesh A New Method for Horizontal Axis Wind Turbine (HAWT) Blade Optimization More cited articles
  1. Adebayo1, A. O., Jekayinfa, S. O. & Linke, B. (2015) Effects of Organic Loading Rate on Biogas Yield in a Continuously Stirred Tank Reactor Experiment at mesophilic temperature, British Journal of Applied Science & Technology. 11(4): 1-9
  2. Altas, L. ( 2009) Inhibitory effect of heavy metals on methane-producing anaerobic granular sludge, J. Hazard. Mater. 162, 1551-1556
  3. Angelidaki, I., & Ahring, B.K. (1993) Thermophilic digestion of livestock waste: the effect of ammonia. Applied Microbiology Biotechnology, 38: 560–564
  4. APHA (American Public Health Association), (1998) Standard methods for the Experimental of Water and Wastewater, APHA Washington, D.C.
  5. Avicenna., Mel, M., Ihsan, S. I., & R. H. Setyobudi, (2015). Process Improvement of Biogas Production from Anaerobic Co-digestion of Cow Dung and Corn Husk. Procedia Chemistry, 14:91-100
  6. Bilgili, M.S., Demir, A. & Varank, G. (2009) Evaluation and modeling of biochemical methane potential (BMP) of landfilled solid waste: a pilot scale study, Bioresource Technology. 100: 4976-4980
  7. Boe, K., & Batstone,D.J. (2005) Optimization of serial CSTR biogas reactors using modeling by ADM1”, In: Proceedings of the First International Workshop on the IWA Anaerobic Digestion Model No. 1 (ADM1), 2–4 September 2005, Lyngby,Denmark, pp. 219–221
  8. Boe,K. .( 2006) Online monitoring and control of the biogas process”, Ph.D. Thesis. Technical University of Denmark. 221 p
  9. Comino,E., Rosso, M. & Riggio,V.( 2013) Investigating of increasing organic loading rate in the co-digestion of energy crops and cow manure mix”, Bioresource Technology, 101: 3013–3019
  10. Deublein, D. , & Steinhauser, A. (2011) Biogas from waste and renewable resources, an introduction: John Wiley & Sons
  11. Estevez, M.M., Linjordet,,R. & Morken, J. (2012) Effects of steam explosion and co-digestion in the methane production from Salix by mesophilic batch assays, Bioresource Technology. 104:749-756
  12. Hartmann, H., Angelidaki, I., & Ahring, B. (2003) Co-digestion of the organic fraction of municipal waste with other waste types,, Biomethanization Organic Fraction Municipal Solid Wastes.181–199
  13. Jagadabhi, P., Lehtomäki, A. & Rintala, J. (2008) Co-digestion of grass silage and cow manure in a CSTR by re-circulation of alkali treated solids of the digested, Environ. Technol. 29: 1085-1093
  14. Karellas, S., Boukis, I., Kontopoulos, G. (2010) Development of an investment decision tool for biogas production from agricultural waste. Renewable and Sustainable Energy Reviews, 14(4): 1273-1282
  15. Karimi, K., Shafiei, M. & Kumar, R. (2013) Progress in physical and chemical pretreatment of lignocelluloses biomass, In: Gupta VK, Tuohy MG, editors. Biofuel technologies. Berlin Heidelberg: Springer, pp. 53–96
  16. Latinwo, G.K., & Agarry, S.E. (2015) Modeling the kinetics of biogas from mesophilic anaerobic co-digestion of cow dung with plantain peels. Int. Journal of Renewable Energy Development 4(1): 55-63
  17. Li, Y., Zhang, R., He. Y., Zhang. Ch., Liu, X., Chen, Ch. & Liu G., (2014)Anaerobic co-digestion of chicken manure and corn Stover in batch and continuously stirred tank reactor (CSTR), Bioresource Technology. 156: 342-347
  18. Lichtman, RJ. (1983) Biogas systems in India. Arlington, USA: Volunteers in Technical Assistance (VITA) in cooperation with the Committee on Science and Technology for Developing Countries (COSTED)
  19. Lo, H.M., Kurniawan, T.A, Sillanpaa, M.E.T, Pai, Y.Y., & Chiang, C.F. (2010) Modeling biogas production from organic fraction of MSW co-digested with MSWI ashes in anaerobic bioreactors. Bioresources Technology, 101:6329-6335
  20. Lyberator G., & Skiades, I.V. (1999) Modeling of anaerobic digestion - A Review”, Global Nest. 1: 63 -76
  21. Maamri, S., & Amrani, M. (2014) Biogas Production from Waste Activated Sludge Using Cattle Dung Inoculums- Effect of Total Solid Contents and Kinetics Study. Ene. Procedia. 50: 352-359
  22. Mata-Alvarez, J., Mace, S. & Llabres, P. (2000) Anaerobic digestion of organic solid wastes, An overview of research achievement and perspectives, Bioresource Technology. 74: 3-16
  23. Mattocks, R. (1984) Understanding biogas generation, Technical Paper, No. 4.Volunteers in Technical Assistance, Virginia, USA,. p. 13
  24. Oliveira, LS., & Franca, AS. (2009) From solid bio wastes to liquid biofuels”, In: Ashworth GS, Azevedo P, editors. Agricultural wastes. New York: Nova Science Publisher
  25. Omer, T.O., & Fedalla M.O. (2002). Engineering design and Economic Evaluation of a family - sized biogas project in Nigeria. Technovation
  26. Pesta, G. (2007) Anaerobic digestion of organic residues and wastes, In: Oreopoulou V, Russ W, editors. Utilization of by-products and treatment of waste in the food industry. New York: Springer; pp. 53–72
  27. Rabah, A. B., Baki, A. S., Hassan, L. G., Musa, M., & Ibrehim, A. D. (2010) Production of biogas using abattoir waste at different time. Science World Journal, 5, 4
  28. Ray, N.H.S., Mohanty, M.K. & Mohanty, R.C. (2016) Biogas Compression and Storage System for Cooking Applications in Rural Households, international journal of renewable energy research. 6(2)
  29. Sanaei- Moghadam, A., Abbaspour-Fard, M.H., Agahel,H.., Aghkhani M.H. & Abedini-Torghbeh, J. (2014) Enhancement of Biogas Production by Co-digestion of Potato Pulp with Cow Manure in a CSTR System. Appl. Biochem. Biotechnol., 173: 1858-1869
  30. Sharma, D.K., (2002) Studies on availability and utilization of onion storage waste in a rural habitat. Ph.D. Thesis, Centre for Rural Development and Technology, Indian Institute of Technology, Delhi, India
  31. Somayaji, D., & Khanna, S. (1994) Biomethanation of rice and wheat straw. World Journal of Microbiology and Biotechnology, 10: 521-523
  32. Song Z, G., Yang, Y., Guo & Zhang,T. (2012) Comparison of tow chemical pretreatments of rice straw for biogas production by anaerobic digestion. Bio Resources, 7: 3223-3236
  33. Taricska, JR., Long, DA., Chen, JP., Hung, YT. & Zou, SW. (2009) Anaerobic Digestion”, In: Wang LK, Pereira NC, Hung YT, editors. “Biological treatment processes”, Hand book of environmental engineering. New York: Humana Press Springer Science, pp.589–634
  34. Themelis, N.J., & Ulloa,P.A. (2007) Methane generation in landfills. Renewable Energy.32 (7), 1243-1257
  35. Tong, Zh., Linlin, L. Zilin,S., Guangxin, R., Youyang,F., Xinhui, H. & Gaphe, Y. (2013) Biogas production by co-digestion of Gout Manure anaerobic with three crop residues. Plos. ONE, 8(6): e66845
  36. Umar, H. S, Firdausi, B. R, Sharifah, R. W. A, & Fadimtu, M. (2013) Biogas production through Co-digestion of palm oil mill effluent with cow manure. Nigerian Journal of Basic and Applied Science, 21(1): 79-84
  37. Wang J. & Wan, W. (2009) Kinetic models for fermentative hydrogen production”, a review. Int. J. Hydrogen Energy. 34, 3313-3323
  38. Wilkie, A.C., & Evans, J. M. (2010) Aquatic plants: an opportunity feedstock in the age of bioenergy, Biofuels. 1, 311–321
  39. Zhang, R., & Zhang, Z. (1999) Bio gasification of rice straw with an anaerobic phased solids digester system, Bioresource Technology. 68: 235-245
  40. Zhang, T., Yang, Y., Liu, L., Han, Ren ,Y. G. & Yang, G. (2014) Improved biogas production from chicken manure anaerobic digestion using cereal residues as co substrates. Energy & Fuels.pubs.acs.org
  41. Zhu, B., Zhang, P., Lord, R.J., Jenkins, B. & Li, X. (2009) Characteristics and biogas production potential of municipal solid waste pretreated with a rotary drum reactor. Bio resource Technology 100:1122-1129
  42. Zwietering, M.H., Jongernburger, I., M.Rombouts, F. & VantsRiet, K. (1990) Modeling of the bacterial growth curve”, Applied and Environmental Microbiology. 56,1875-1881

Last update:

  1. Effect of Organic Waste Addition into Animal Manure on Biogas Production Using Anaerobic Digestion Method

    Fahmi Arifan, Abdullah Abdullah, Siswo Sumardiono. International Journal of Renewable Energy Development, 10 (3), 2021. doi: 10.14710/ijred.2021.36107

  2. Enhancement of biogas production from rice husk using mechanical pretreatment (grinding) in Liquid Anaerobic Digestion (L-AD)

    Syafrudin, Winardi Dwi Nugraha, Soraya Annisa Putri, Hashfi Hawali Abdul Matin, Budiyono, B. Warsito, Sudarno, T. Triadi Putranto. E3S Web of Conferences, 202 , 2020. doi: 10.1051/e3sconf/202020208003

  3. Preliminary Observation of Biogas Production from a Mixture of Cattle Manure and Bagasse Residue in Different Composition Variations

    H Hadiyanto, Figa Muhammad Octafalahanda, Jihan Nabila, Andono Kusuma Jati, Marcelinus Christwardana, Kusmiyati Kusmiyati, Adian Khoironi. International Journal of Renewable Energy Development, 12 (2), 2023. doi: 10.14710/ijred.2023.52446

  4. Understanding Anaerobic Co-digestion of Organic Wastes through Meta-Analysis

    Wachiranon Chuenchart, K. C. Surendra, Samir Kumar Khanal. ACS ES&T Engineering, 4 (5), 2024. doi: 10.1021/acsestengg.3c00598

  5. Technical prospects and challenges of anaerobic co-digestion in Bangladesh: A review

    Chayan Kumer Saha, Rajesh Nandi, Shammi Akter, Samira Hossain, Kazi Bayzid Kabir, Kawnish Kirtania, Md Tahmid Islam, Laura Guidugli, M. Toufiq Reza, Md Monjurul Alam. Renewable and Sustainable Energy Reviews, 197 , 2024. doi: 10.1016/j.rser.2024.114412

Last update: 2024-11-21 23:07:29

  1. Enhancement of biogas production from rice husk using mechanical pretreatment (grinding) in Liquid Anaerobic Digestion (L-AD)

    Syafrudin, Winardi Dwi Nugraha, Soraya Annisa Putri, Hashfi Hawali Abdul Matin, Budiyono, B. Warsito, Sudarno, T. Triadi Putranto. E3S Web of Conferences, 202 , 2020. doi: 10.1051/e3sconf/202020208003